In this article, we consider the fourth-generation Ford E-Series (third refresh), produced from 2009 to 2012. Here you will find fuse box diagrams of Ford E-Series 2009, 2010, 2011 and 2012 (E-150, E-250, E-350, E-450), get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
Fuse Layout Ford E-Series 2009-2012
Contents
Cigar lighter (power outlet) fuses in the Ford E-Series are the fuses №65 (Power point 2 (glove box)), №66 (Power point 3 (left-hand B-pillar)), №67 (Power point 1 (instrument panel)) and №72 (Cigar lighter) in the Engine compartment fuse box.
Table of Contents
Fuse box location
Fuse box location
Passenger compartment
The fuse panel is located to the left of the brake pedal and mounted onto the lower left cowl panel.
Engine compartment
The power distribution box is located in the engine compartment.
Fuse box diagrams
Fuse box diagrams
2009
Passenger compartment
Assignment of the fuses in the Passenger compartment (2009)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | 30A | Not used (spare) |
| 2 | 15A | Not used (spare) |
| 3 | 15A | Not used (spare) |
| 4 | 30A | Not used (spare) |
| 5 | 10A | SPDJB/Brake shift interlock |
| 6 | 20A | Turn signal, Hazard, Stop lamps |
| 7 | 10A | Left low beam |
| 8 | 10A | Right low beam |
| 9 | 15A | Courtesy lamps |
| 10 | 15A | Switch illumination |
| 11 | 10A | Not used (spare) |
| 12 | 7.5A | Not used (spare) |
| 13 | 5A | Mirrors |
| 14 | 10A | Not used (spare) |
| 15 | 10A | Not used (spare) |
| 16 | 15A | Not used (spare) |
| 17 | 20A | Door locks |
| 18 | 20A | Not used (spare) |
| 19 | 25A | Not used (spare) |
| 20 | 15A | Diagnostic connector (except stripped chassis) |
| 21 | 15A | Not used (spare) |
| 22 | 15A | Park lamps, License plate lamps |
| 23 | 15A | High beams |
| 24 | 20A | Horn (except stripped chassis) |
| 25 | 10A | Demand lighting |
| 26 | 10A | Cluster (except stripped chassis) |
| 27 | 20A | Ignition switch feed |
| 28 | 5A | Audio mute (start) |
| 29 | 5A | Cluster (except stripped chassis) |
| 30 | 5A | Not used (spare) |
| 31 | 10A | Not used (spare) |
| 32 | 10A | Restraints module |
| 33 | 10A | Trailer Brake Controller |
| 34 | 5A | Not used (spare) |
| 35 | 10A | Reverse park aid, Rear video camera, Cutaway run/start |
| 36 | 5A | PATS RF module |
| 37 | 10A | Climate control, Stripped chassis IP #1 run/start |
| 38 | 20A | Not used (spare) |
| 39 | 20A | Radio, Navigation |
| 40 | 20A | Amplifier |
| 41 | 15A | Radio, Switch illumination, Reverse camera mirror |
| 42 | 10A | Upfitter switch |
| 43 | 10A | Overhead console, Stripped chassis IP1 |
| 44 | 10A | Auxiliary battery relay/Trailer tow battery charger relay |
| 45 | 5A | Wipers, Stripped chassis Engine connector 3 |
| 46 | 7.5A | PADI |
| 47 | 30A circuit breaker | Windows accessory delay |
| 48 | Relay | Delayed accessoiy |
Engine compartment
Assignment of the fuses in the Power distribution box (2009)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | HC Micro Relay | Powertrain Control Module (PCM) |
| 2 | HC Micro Relay | Starter solenoid |
| 3 | HC Micro Relay | Wiper |
| 4 | HC Micro Relay | Trailer tow battery charge |
| 5 | HC Micro Relay | Fuel pump |
| 6 | HC Micro Relay | Trailer tow park lamp |
| 7 | HC Micro Relay | Upfitter #4 |
| 8 | HC Micro Relay | Upfitter #3 |
| 9 | HC Micro Relay | Modified vehicle and stripped chassis run/start |
| 10 | HC ISO | IDM relay (Diesel engine only) |
| 11 | — | Not used |
| 12 | 40A** | Modified vehicle and stripped chassis run/start |
| 13 | 30A** | Starter solenoid relay |
| 14 | 40A** | Run start relay |
| 15 | 40A** | Modified vehicle and stripped chassis battery |
| 16 | 50A** | Auxiliary A/C blower |
| 17 | 50A** | Auxiliary battery feed, Trailer tow battery charge, trailer tow park feed |
| 18 | 30A** | Electric trailer brake, Trailer brake controller |
| 19 | 30A** | Upfitter #1 |
| 20 | 30A** | Upfitter #2 |
| 21 | 50A** | IDM relay (diesel engine only) |
| 22 | — | Not used |
| 23 | G8VA relay | A/C clutch |
| 24 | G8VA relay | Horn relay (Stripped chassis) |
| 25 | HC Micro relay | Run/start |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 20 A* | Back up lamp |
| 29 | 10 A* | A/C clutch |
| 30 | 10 A* | BOO switch |
| 31 | 10A* | Cluster battery (stripped chassis only), IDM coil (diesel engine only) |
| 32 | 50A** | Blower motor |
| 33 | 40A** | ABS pump |
| 34 | 20A** | Stripped chassis horn |
| 35 | 40A** | PCM relay |
| 36 | 20A** | Ignition switch (Stripped chassis only) |
| 37 | G8VA relay | Trailer tow stop/LH turn signal |
| 38 | G8VA relay | Trailer tow stop/RH turn signal |
| 39 | G8VA relay | Back up lamp |
| 40 | ISO relay | Blower motor |
| 41 | 10 A* | Charging (diesel engine only) |
| 42 | 15 A* | Diagnostic connector (stripped chassis) |
| 43 | 20 A* | Fuel pump |
| 44 | 10 A* | UpFitter #3 |
| 45 | 15 A* | UpFitter #4 |
| 46 | 10 A* | PCM keep alive power, Canister vent, PCM relay coil |
| 47 | 40A** | ABS coH |
| 48 | 20A** | Trailer tow stop lamp/turn signal |
| 49 | 30A** | Wiper motor |
| 50 | — | Not used |
| 51 | 20A** | Cutaway |
| 52 | 10 A* | Stripped chassis and modified vehicle run/start relay coil |
| 53 | 10 A* | ABS run/start feed |
| 54 | 10 A* | Fuel pump relay coil (gas engine only) |
| 55 | 10 A* | ECM (diesel engine only) |
| 56 | 20A* | DFCM (diesel engine only) |
| 57 | 20 A* | Trailer tow park lamp |
| 58 | 15 A* | Trailer tow backup lamp |
| 59 | — | Not used |
| 60 | — | One Touch Integrated Start (OTIS) (diode) |
| 61 | — | Auxiliary battery (diode) |
| 62 | HC Micro relay | UpFitter #2 |
| 63 | 30A** | Trailer tow battery charge |
| 64 | — | Not used |
| 65 | 20A** | Power point 2 (glove box) |
| 66 | 20A** | Power point 3 (left-hand B-pillar) |
| 67 | 20A** | Power point 1 (instrument panel) |
| 68 | 50A** | Modified vehicle |
| 69 | — | Not used |
| 70 | 30A** | Stripped chassis |
| 71 | — | Not used |
| 72 | 20A** | Cigar lighter |
| 73 | — | Not used |
| 74 | 30A** | Power seat |
| 75 | 20 A* | VPWR 1, PCM power |
| 76 | 20 A* | VPWR 2, PCM mil |
| 77 | 10 A* | VPWR 3, PCM non mil |
| 78 | 15 A* | VPWR 4 (gas engine only), Ignition coil (diesel engine only), Fuel pump relay coil |
| 79 | 10 A* | VPWR 5, Transmission |
| 80 | 10 A* | Cluster run/start (stripped chassis only) |
| 81 | 15 A* | IDM logic (diesel engine only) |
| 82 | — | Not used |
| 83 | — | Fuel pump (diode) |
| 84 | — | Not used |
| 85 | HC Micro relay | UpFitter #1 |
| * Mini fuses ** A1S fuses |
2010
Passenger compartment
Assignment of the fuses in the Passenger compartment (2010)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | 30A | Not used (spare) |
| 2 | 15A | Not used (spare) |
| 3 | 15A | Not used (spare) |
| 4 | 30A | Not used (spare) |
| 5 | 10A | Passenger compartment fuse panel (SPDJB)/Brake-shift interlock |
| 6 | 20A | Turn signal, Hazard, Stop lamps |
| 7 | 10A | Left low beam |
| 8 | 10A | Right low beam |
| 9 | 15A | Courtesy lamps |
| 10 | 15A | Switch illumination |
| 11 | 10A | Not used (spare) |
| 12 | 7.5A | Not used (spare) |
| 13 | 5A | Mirrors |
| 14 | 10A | SYNC®, GPS module |
| 15 | 10A | Satellite radio |
| 16 | 15A | Not used (spare) |
| 17 | 20A | Door locks |
| 18 | 20A | Not used (spare) |
| 19 | 25A | Not used (spare) |
| 20 | 15A | Diagnostic connector (except stripped chassis) |
| 21 | 15A | Not used (spare) |
| 22 | 15A | Park lamps, License plate lamps |
| 23 | 15A | High beams |
| 24 | 20A | Horn (except stripped chassis) |
| 25 | 10A | Demand lighting |
| 26 | 10A | Cluster (except stripped chassis) |
| 27 | 20A | Ignition switch feed |
| 28 | 5A | Audio mute (start) |
| 29 | 5A | Cluster (except stripped chassis) |
| 30 | 5A | Not used (spare) |
| 31 | 10A | Not used (spare) |
| 32 | 10A | Restraints module |
| 33 | 10A | Trailer brake controller |
| 34 | 5A | Not used (spare) |
| 35 | 10A | Reverse park aid, Rear video camera, Cutaway run/start |
| 36 | 5A | Passive anti-theft system (PATS) RF module |
| 37 | 10A | Climate control, Stripped chassis IP #1 run/start |
| 38 | 20A | Not used (spare) |
| 39 | 20A | Radio, Navigation |
| 40 | 20A | Amplifier |
| 41 | 15A | Radio, Switch illumination, Reverse camera mirror, Automatic dimming rear view mirror |
| 42 | 10A | Upfitter switch |
| 43 | 10A | Stripped chassis IP connector #1 |
| 44 | 10A | Auxiliary batteiy relay/Trailer tow battery charger relay |
| 45 | 5A | Wipers, Stripped chassis Engine connector 3 |
| 46 | 7.5A | Passenger airbag deactivation indicator (PADI) |
| 47 | 30A circuit breaker | Windows accessory delay |
| 48 | Relay | Delayed accessory |
Engine compartment
Assignment of the fuses in the Power distribution box (2010)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | HC Micro Relay | Powertrain control module (PCM) |
| 2 | HC Micro Relay | Starter solenoid |
| 3 | HC Micro Relay | Wiper |
| 4 | HC Micro Relay | Trailer tow battery charge |
| 5 | HC Micro Relay | Fuel pump |
| 6 | HC Micro Relay | Trailer tow park lamp |
| 7 | HC Micro Relay | Upfitter #4 |
| 8 | HC Micro Relay | Upfitter #3 |
| 9 | HC Micro Relay | Modified vehicle and stripped chassis run/start |
| 10 | HC ISO | Fuel injector control module (FICM) relay (Diesel engine only) |
| 11 | — | Not used |
| 12 | 40A** | Modified vehicle and stripped chassis run/start |
| 13 | 30A** | Starter solenoid relay |
| 14 | 40A** | Run start relay |
| 15 | 40A** | Modified vehicle and stripped chassis batteiy |
| 16 | 50A** | Auxiliary A/C blower |
| 17 | 50A** | Auxiliary batteiy feed, Trailer tow battery charge, trailer tow park feed |
| 18 | 30A** | Electric trailer brake, Trailer brake controller |
| 19 | 30A** | Upfitter #1 |
| 20 | 30A** | Upfitter #2 |
| 21 | 50A** | FICM relay (diesel engine only) |
| 22 | — | Not used |
| 23 | G8VA relay | A/C clutch |
| 24 | G8VA relay | Horn relay (Stripped chassis) |
| 25 | HC Micro relay | Run/start |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 20A* | Back up lamp |
| 29 | 10 A* | A/C clutch |
| 30 | 10 A* | Brake on/off (BOO) switch |
| 31 | 10 A* | Cluster battery (stripped chassis only), FICM coil (diesel engine only) |
| 32 | 50A** | Blower motor |
| 33 | 40A** | Anti-lock brake system (ABS) pump |
| 34 | 20A** | Stripped chassis horn |
| 35 | 40A** | PCM relay |
| 36 | 20A** | Ignition switch (Stripped chassis only) |
| 37 | G8VA relay | Trailer tow stop — left turn signal |
| 38 | G8VA relay | Trailer tow stop — right turn signal |
| 39 | G8VA relay | Back up lamp |
| 40 | ISO relay | Blower motor |
| 41 | 10 A* | Charging (diesel engine only) |
| 42 | 15 A* | Diagnostic connector (stripped chassis) |
| 43 | 20 A* | Fuel pump |
| 44 | 10 A* | Upfitter #3 |
| 45 | 15 A* | Upfitter #4 |
| 46 | 10 A* | PCM keep alive power, Canister vent, PCM relay coil |
| 47 | 40A** | ABS coil |
| 48 | 20A** | Trailer tow stop lamp/turn signal |
| 49 | 30A** | Wiper motor |
| 50 | — | Not used |
| 51 | 20A** | Cutaway |
| 52 | 10 A* | Stripped chassis and modified vehicle run/start relay coil |
| 53 | 10 A* | ABS run/start feed |
| 54 | 10 A* | Fuel pump relay coil (gas engine only) |
| 55 | 10 A* | PCM (diesel engine only) |
| 56 | 20A* | Diesel fuel conditioner module (DFCM) (diesel engine only) |
| 57 | 20A* | Trailer tow park lamp |
| 58 | 15 A* | Trailer tow backup lamp |
| 59 | — | Not used |
| 60 | — | One touch integrated start (OTIS) (diode) |
| 61 | — | Auxiliary batteiy (diode) |
| 62 | HC Micro relay | Upfitter #2 |
| 63 | 30A** | Trailer tow battery charge |
| 64 | — | Not used |
| 65 | 20A** | Power point 2 (glove box) |
| 66 | 20A** | Power point 3 (left-hand B-pillar) |
| 67 | 20A** | Power point 1 (instrument panel) |
| 68 | 50A** | Modified vehicle |
| 69 | — | Not used |
| 70 | 30A** | Stripped chassis |
| 71 | — | Not used |
| 72 | 20 A** | Cigar lighter |
| 73 | — | Not used |
| 74 | 30A** | Power seat |
| 75 | 20A* | Vehicle power (VPWR) 1, PCM power |
| 76 | 20A* | VPWR 2, PCM – emission related powertrain components |
| 77 | 10 A* | VPWR 3, PCM – general powertrain components |
| 78 | 15 A* | VPWR 4 (gas engine only), Ignition coil (diesel engine only), Fuel pump relay coil |
| 79 | 10 A* | VPWR 5, Transmission |
| 80 | 10 A* | Cluster run/start (stripped chassis only) |
| 81 | 15 A* | FICM logic (diesel engine only) |
| 82 | — | Not used |
| 83 | — | Fuel pump (diode) |
| 84 | — | Not used |
| 85 | HC Micro relay | Upfitter #1 |
| * Mini fuses ** A1S fuses |
2011
Passenger compartment
Assignment of the fuses in the Passenger compartment (2011)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | 30A | Not used (spare) |
| 2 | 15A | Not used (spare) |
| 3 | 15A | Not used (spare) |
| 4 | 30A | Not used (spare) |
| 5 | 10A | Passenger compartment fuse panel (SPDJB)/Brake-shift interlock |
| 6 | 20A | Turn signal, Hazard, Stop lamps |
| 7 | 10A | Left low beam |
| 8 | 10A | Right low beam |
| 9 | 15A | Courtesy lamps |
| 10 | 15A | Switch illumination |
| 11 | 10A | Not used (spare) |
| 12 | 7.5A | Not used (spare) |
| 13 | 5A | Mirrors |
| 14 | 10A | SYNC®, GPS module |
| 15 | 10A | Satellite radio |
| 16 | 15A | Not used (spare) |
| 17 | 20A | Door locks |
| 18 | 20A | Not used (spare) |
| 19 | 25A | Not used (spare) |
| 20 | 15A | Diagnostic connector (except stripped chassis) |
| 21 | 15A | Not used (spare) |
| 22 | 15A | Park lamps, License plate lamps |
| 23 | 15A | High beams |
| 24 | 20A | Horn (except stripped chassis) |
| 25 | 10A | Demand lighting |
| 26 | 10A | Cluster (except stripped chassis) |
| 27 | 20A | Ignition switch feed |
| 28 | 5A | Audio mute (start) |
| 29 | 5A | Cluster (except stripped chassis) |
| 30 | 5A | Not used (spare) |
| 31 | 10A | Not used (spare) |
| 32 | 10A | Restraints module |
| 33 | 10A | Trailer brake controller |
| 34 | 5A | Not used (spare) |
| 35 | 10A | Reverse park aid, Rear video camera, Cutaway run/start |
| 36 | 5A | Passive anti-theft system (PATS) RF module |
| 37 | 10A | Climate control, Stripped chassis IP #1 run/start |
| 38 | 20A | Not used (spare) |
| 39 | 20A | Radio, Navigation |
| 40 | 20A | Amplifier |
| 41 | 15A | Radio, Switch illumination, Reverse camera mirror, Automatic dimming rear view mirror |
| 42 | 10A | Upfitter switch |
| 43 | 10A | Stripped chassis IP connector #1 |
| 44 | 10A | Auxiliary battery relay/Trailer tow battery charger relay |
| 45 | 5A | Wipers, Stripped chassis Engine connector 3 |
| 46 | 7.5A | Passenger airbag deactivation indicator (PADI) |
| 47 | 30A circuit breaker | Windows accessory delay |
| 48 | Relay | Delayed accessory |
Engine compartment
Assignment of the fuses in the Power distribution box (2011)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | HC Micro Relay | Powertrain control module (PCM) |
| 2 | HC Micro Relay | Starter solenoid |
| 3 | HC Micro Relay | Wiper |
| 4 | HC Micro Relay | Trailer tow battery charge |
| 5 | HC Micro Relay | Fuel pump |
| 6 | HC Micro Relay | Trailer tow park lamp |
| 7 | HC Micro Relay | Upfitter #4 |
| 8 | HC Micro Relay | Upfitter #3 |
| 9 | HC Micro Relay | Modified vehicle and stripped chassis run/start |
| 10 | — | Not used |
| 11 | — | Not used |
| 12 | 40A** | Modified vehicle and stripped chassis run/start |
| 13 | 30A** | Starter solenoid relay |
| 14 | 40A** | Run start relay |
| 15 | 40A** | Modified vehicle and stripped chassis battery |
| 16 | 50A** | Auxiliary A/C blower |
| 17 | 50A** | Auxiliary battery feed, Trailer tow battery charge, trailer tow park feed |
| 18 | 30A** | Electric trailer brake, Trailer brake controller |
| 19 | 30A** | Upfitter #1 |
| 20 | 30A** | Upfitter #2 |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | G8VA relay | A/C clutch |
| 24 | G8VA relay | Horn relay (stripped chassis) |
| 25 | HC Micro relay | Run/start |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 20 A* | Back up lamp |
| 29 | 10 A* | A/C clutch |
| 30 | 10 A* | Brake on/off (BOO) switch |
| 31 | 10 A* | Cluster batteiy (stripped chassis) |
| 32 | 50A** | Blower motor |
| 33 | 40A** | Anti-lock brake system (ABS) pump |
| 34 | 20A** | Stripped chassis horn |
| 35 | 40A** | PCM relay |
| 36 | 20A** | Ignition switch (stripped chassis) |
| 37 | G8VA relay | Trailer tow stop — left turn signal |
| 38 | G8VA relay | Trailer tow stop — right turn signal |
| 39 | G8VA relay | Back up lamp |
| 40 | ISO relay | Blower motor |
| 41 | — | Not used |
| 42 | 15 A* | Diagnostic connector (stripped chassis) |
| 43 | 20 A* | Fuel pump |
| 44 | 10 A* | UpFitter #3 |
| 45 | 15 A* | UpFitter #4 |
| 46 | 10 A* | PCM keep alive power, Canister vent, PCM relay coil |
| 47 | 40A** | ABS coil |
| 48 | 20A** | Trailer tow stop lamp/turn signal |
| 49 | 30A** | Wiper motor |
| 50 | — | Not used |
| 51 | 20A** | Cutaway |
| 52 | 10 A* | Stripped chassis and modified vehicle run/start relay coil |
| 53 | 10 A* | ABS run/start feed |
| 54 | 10 A* | Fuel pump relay coil |
| 55 | — | Not used |
| 56 | — | Not used |
| 57 | 20 A* | Trailer tow park lamp |
| 58 | 15 A* | Trailer tow backup lamp |
| 59 | — | Not used |
| 60 | — | One touch integrated start (OTIS) (diode) |
| 61 | — | Auxiliary battery (diode) |
| 62 | HC Micro relay | Upfitter #2 |
| 63 | 30A** | Trailer tow battery charge |
| 64 | — | Not used |
| 65 | 20A** | Power point 2 (glove box) |
| 66 | 20A** | Power point 3 (left-hand B-pillar) |
| 67 | 20A** | Power point 1 (instrument panel) |
| 68 | 50A** | Modified vehicle |
| 69 | — | Not used |
| 70 | 30A** | Stripped chassis |
| 71 | — | Not used |
| 72 | 20A** | Cigar lighter |
| 73 | — | Not used |
| 74 | 30A** | Power seat |
| 75 | 20 A* | Vehicle power (VPWR) 1, PCM power |
| 76 | 20 A* | VPWR 2, PCM – emission related powertrain components |
| 77 | 10 A* | VPWR 3, PCM – general powertrain components |
| 78 | 15 A* | VPWR 4, Fuel pump relay coil |
| 79 | 10 A* | VPWR 5, Transmission |
| 80 | 10 A* | Cluster run/start (stripped chassis) |
| 81 | — | Not used |
| 82 | — | Not used |
| 83 | — | Fuel pump (diode) |
| 84 | — | Not used |
| 85 | HC Micro relay | Upfitter #1 |
| * Mini fuses ** A1S fuses |
2012
Passenger compartment
Assignment of the fuses in the Passenger compartment (2012)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | 30A | Not used (spare) |
| 2 | 15A | Not used (spare) |
| 3 | 15A | Not used (spare) |
| 4 | 30A | Not used (spare) |
| 5 | 10A | Passenger compartment fuse panel (SPDJB)/Brake-shift interlock |
| 6 | 20A | Turn signal, Hazard, Stop lamps |
| 7 | 10A | Left low beam |
| 8 | 10A | Right low beam |
| 9 | 15A | Courtesy lamps |
| 10 | 15A | Switch illumination |
| 11 | 10A | Not used (spare) |
| 12 | 7.5A | Not used (spare) |
| 13 | 5A | Mirrors |
| 14 | 10A | SYNC®, GPS module |
| 15 | 10A | Not used (spare) |
| 16 | 15A | Not used (spare) |
| 17 | 20A | Door locks |
| 18 | 20A | Not used (spare) |
| 19 | 25A | Not used (spare) |
| 20 | 15A | Diagnostic connector (except stripped chassis) |
| 21 | 15A | Not used (spare) |
| 22 | 15A | Park lamps, License plate lamps |
| 23 | 15A | High beams |
| 24 | 20A | Horn (except stripped chassis) |
| 25 | 10A | Demand lighting |
| 26 | 10A | Cluster (except stripped chassis) |
| 27 | 20A | Ignition switch feed |
| 28 | 5A | Audio mute (start) |
| 29 | 5A | Cluster (except stripped chassis) |
| 30 | 5A | Not used (spare) |
| 31 | 10A | Not used (spare) |
| 32 | 10A | Restraints module |
| 33 | 10A | Trailer brake controller |
| 34 | 5A | Not used (spare) |
| 35 | 10A | Reverse park aid, Rear video camera, Cutaway run/start |
| 36 | 5A | Passive anti-theft system (PATS) RF module |
| 37 | 10A | Climate control, Stripped chassis IP #1 run/start |
| 38 | 20A | Not used (spare) |
| 39 | 20A | Radio, Navigation |
| 40 | 20A | Amplifier |
| 41 | 15A | Radio, Switch illumination, Reverse camera mirror, Automatic dimming rear view mirror |
| 42 | 10A | Upfitter switch |
| 43 | 10A | Stripped chassis IP connector #1 |
| 44 | 10A | Trailer tow battery charge relay |
| 45 | 5A | Wipers, Stripped chassis Engine connector 3 |
| 46 | 7.5A | Passenger airbag deactivation indicator (PADI) |
| 47 | 30A circuit breaker | Windows accessory delay |
| 48 | Relay | Delayed accessory |
Engine compartment
Assignment of the fuses in the Power distribution box (2012)
| № | Amp Rating | Protected Circuits |
|---|---|---|
| 1 | HC Micro Relay | Powertrain control module (PCM) |
| 2 | HC Micro Relay | Starter solenoid |
| 3 | HC Micro Relay | Wiper |
| 4 | HC Micro Relay | Trailer tow battery charge |
| 5 | HC Micro Relay | Fuel pump |
| 6 | HC Micro Relay | Trailer tow park lamp |
| 7 | HC Micro Relay | Upfitter #4 |
| 8 | HC Micro Relay | Upfitter #3 |
| 9 | HC Micro Relay | Modified vehicle and stripped chassis run/start |
| 10 | — | Not used |
| 11 | — | Not used |
| 12 | 40A** | Modified vehicle and stripped chassis run/start |
| 13 | 30A** | Starter solenoid relay |
| 14 | 40A** | Run start relay |
| 15 | 40A** | Modified vehicle and stripped chassis batteiy |
| 16 | 50A** | Auxiliary A/C blower |
| 17 | 50A** | Trailer tow battery charge, Trailer tow park feed |
| 18 | 30A** | Electric trailer brake, Trailer brake controller |
| 19 | 30A** | Upfitter #1 |
| 20 | 30A** | Upfitter #2 |
| 21 | — | Not used |
| 22 | — | Not used |
| 23 | G8VA relay | A/C clutch |
| 24 | G8VA relay | Horn relay (stripped chassis) |
| 25 | HC Micro relay | Run/start |
| 26 | — | Not used |
| 27 | — | Not used |
| 28 | 20 A* | Back up lamp |
| 29 | 10 A* | A/C clutch |
| 30 | 10 A* | Brake on/off (BOO) switch |
| 31 | 10 A* | Cluster battery (stripped chassis) |
| 32 | 50A** | Blower motor |
| 33 | 40A** | Anti-lock brake system (ABS) pump |
| 34 | 20A** | Stripped chassis horn |
| 35 | 40A** | PCM relay |
| 36 | 20A** | Ignition switch (stripped chassis) |
| 37 | G8VA relay | Trailer tow stop — left turn signal |
| 38 | G8VA relay | Trailer tow stop — right turn signal |
| 39 | G8VA relay | Back up lamp |
| 40 | ISO relay | Blower motor |
| 41 | — | Not used |
| 42 | 15 A* | Diagnostic connector (stripped chassis) |
| 43 | 20 A* | Fuel pump |
| 44 | 10 A* | Upfitter #3 |
| 45 | 15 A* | Upfitter #4 |
| 46 | 10 A* | PCM keep alive power, Canister vent, PCM relay coil |
| 47 | 40A** | ABS coil |
| 48 | 20A** | Trailer tow stop lamp/turn signal |
| 49 | 30A** | Wiper motor |
| 50 | — | Not used |
| 51 | 20A** | Cutaway |
| 52 | 10 A* | Stripped chassis and modified vehicle run/start relay coil |
| 53 | 10 A* | ABS run/start feed |
| 54 | 10 A* | Fuel pump relay coil |
| 55 | — | Not used |
| 56 | — | Not used |
| 57 | 20A* | Trailer tow park lamp |
| 58 | 15 A* | Trailer tow backup lamp |
| 59 | — | Not used |
| 60 | — | One touch integrated start (OTIS) (diode) |
| 61 | — | Not used |
| 62 | HC Micro relay | Upfitter #2 |
| 63 | 30A** | Trailer tow battery charge |
| 64 | — | Not used |
| 65 | 20 A** | Power point 2 (glove box) |
| 66 | 20 A** | Power point 3 (left-hand B-pillar) |
| 67 | 20 A** | Power point 1 (instrument panel) |
| 68 | 50A** | Modified vehicle |
| 69 | — | Not used |
| 70 | 30A** | Stripped chassis |
| 71 | — | Not used |
| 72 | 20A** | Cigar lighter |
| 73 | — | Not used |
| 74 | 30A** | Power seat |
| 75 | 20 A* | Vehicle power (VPWR) 1, PCM power |
| 76 | 20 A* | VPWR 2, PCM – emission related powertrain components |
| 77 | 10 A* | VPWR 3, PCM – general powertrain components |
| 78 | 15 A* | VPWR 4, Fuel pump relay coil |
| 79 | 10 A* | VPWR 5, Transmission |
| 80 | 10 A* | Cluster run/start (stripped chassis) |
| 81 | — | Not used |
| 82 | — | Not used |
| 83 | — | Fuel pump (diode) |
| 84 | — | Not used |
| 85 | HC Micro relay | Upfitter #1 |
| * Mini fuses ** A1S fuses |
