In this article, we consider the fifth-generation Toyota HiAce (H200) after a facelift, produced from 2014 to 2018. Here you will find fuse box diagrams of Toyota HiAce 2014, 2015, 2016, 2017 and 2018, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
See other Toyota HiAce:
Fuse Layout Toyota HiAce 2014-2018
Contents
Cigar lighter (power outlet) fuse in the Toyota HiAce is the fuse #23 “CIG” in the Instrument panel fuse box.
Table of Contents
Passenger Compartment Fuse Box
Passenger Compartment Fuse Box
Fuse box location
Left-hand drive vehicles
Right-hand drive vehicles
- Door Control Relay (RH)
- Door Opening Relay (RH)
- Door Control Relay (Power Slide Door RH)
- Door Control Relay (Power Slide Door LH)
- Door Control Receiver
- Door Opening Relay (LH)
- Door Control Relay (LH)
The fuse box is located under the instrument panel, under the cover.
Fuse box diagram
Assignment of the fuses in the Passenger Compartment
| № | Name | Amp | Circuit |
|---|---|---|---|
| 1 | WIP FR | 25 | Front wiper and washer |
| 2 | R/B INPANE | 20 | Power source |
| 3 | ACCL INT LCK | 25 | |
| 4 | WIP/WSH RR | 15 | Rear wiper and washer |
| 5 | WSH FR | 10 | Front wiper and washer |
| 6 | ECU-IG NO. 1 | 7.5 | ABS, shift lock |
| 7 | GAUGE NO. 1 | 10 | Charging, clock, combination meter, cooling fan, entry and start system, front air conditioner, interior light, power slide door, power window, PTC heater (1KD-FTV, 2KD-FTV), rear window defogger, seat belt warning, wireless door lock control, multiport fuel injection system/sequential multiport fuel injection system |
| 8 | OBD II | 7.5 | On-board diagnosis system |
| 9 | STOP NO. 1 | 10 | Stop light, ABS, cruise control, multiport fuel injection system/sequential multiport fuel injection system, entry and start system, shift lock |
| 10 | – | – | – |
| 11 | DOOR | 30 | Door lock control, automatic light control, daytime running light, entry and start system, front fog light, headlight, headlight beam level control, illumination, interior light, key reminder, light reminder, power slide door, power window , rear fog light, taillight, wireless door lock control |
| 12 | HTR RR | 15 | Rear air conditioner |
| 13 | – | – | – |
| 14 | FR FOG | 10 | Front fog light |
| 15 | AM1 | 10 | Starting system |
| 16 | TAIL | 10 | Taillight, front fog light, rear fog light, multiport fuel injection system/sequential multiport fuel injection system |
| 17 | PANEL NO. 1 | 10 | Clock, combination meter, daytime running light, illumination, key reminder, light reminder, taillight |
| 18 | A/C NO. 1 | 10 | Cooling fan (5L-E), front air conditioner, PTC heater (1KD-FTV, 2KD-FTV), rear air conditioner |
| 19 | – | – | – |
| 20 | – | – | – |
| 21 | – | – | – |
| 22 | – | – | – |
| 23 | CIG | 15 | Cigarette lighter |
| 24 | ACC NO. 1 | 7.5 | Audio system, remote control mirror |
| 25 | ACC NO. 2 | 7.5 | Shift lock |
| 26 | – | – | – |
| 27 | – | – | – |
| 28 | RR FOG | 10 | Rear fog light |
| 29 | WELCAB | 15 | – |
| 30 | A/B | 15 | SRS, clock, combination meter |
| 31 | MET IGN | 10 | ABS, back-up light, charging, clock, combination meter, daytime running light, entry and start system, front air conditioner, headlight, headlight beam level control (automatic), illumination, interior light, key reminder, light reminder, power slide door (LHD), PTC heater (1KD-FTV, 2KD-FTV), seat belt warning, srs, taillight, turn signal and hazard warning light, wireless door lock control (LHD), multiport fuel injection system/sequential multiport fuel injection system |
| № | Name | Amp | Circuit |
|---|---|---|---|
| 1 | POWER | 30 | Power windows |
| 2 | – | – | – |
| 3 | ACC | 30 | Entry and start system |
| Relay | |||
| R1 | Ignition (IG1) | ||
| R2 | Heater (HTR) |
Additional Fuse Box
It is located under the instrument panel, behind the cover (on right – on LHD, on left – on RHD).
Left-hand drive vehicles
Right-hand drive vehicles
Passenger Compartment Additional Fuse Box
| № | Name | Amp | Circuit |
|---|---|---|---|
| 1 | – | – | – |
| 2 | – | – | – |
| 3 | – | – | – |
| 4 | DRL | 10 | Daytime running light |
| 5 | IGN NO.2 | 10 | Multiport fuel injection system/sequential multiport fuel injection system |
| 6 | IGN NO.1 | 15 | Multiport fuel injection system/sequential multiport fuel injection system |
| 7 | IG2-MAIN | 30 | Entry and start system |
| 8 | H-LP RH-LO | 10 | LED: Right-hand headlight (Low), automatic light control, headlight beam level control (automatic) |
| 9 | H-LP LH-LO | 10 | LED: Left-hand headlight (Low), automatic light control, headlight beam level control (automatic) |
| 10 | H-LP RH-HI | 10 | LED: Right-hand headlight (High), headlight beam level control (automatic) |
| 11 | H-LP LH-HI | 10 | LED: Left-hand headlight (High), headlight beam level control (automatic) |
| 12 | SPARE | – | Spare fuse |
| 13 | SPARE | – | Spare fuse |
| 14 | SPARE | – | Spare fuse |
| 15 | – | – | LHD: – |
| 16 | STOP NO.2 | 7.5 | Multiport fuel injection system/sequential multiport fuel injection system |
| 17 | A/C NO.2 | 7.5 | Front air conditioner |
| 18 | ST | 7.5 | Starting system, multiport fuel injection system/sequential multiport fuel injection system |
| 19 | H-LP LH-HI | 10 | Halogen: Left-hand headlight (High) |
| 20 | H-LP RH-HI | 10 | Halogen: Right-hand headlight (High) |
| 21 | H-LP LH-LO | 10 | Halogen: Left-hand headlight (Low), headlight beam level control (manual) |
| 22 | H-LP RH-LO | 10 | Halogen: Right-hand headlight (Low) |
| 23 | ECU IG NO.2 | 7.5 | Automatic glare-resistant EC mirror, automatic light control, daytime running light, door lock control (LHD), entry and start system, front fog light, headlight, headlight beam level control, illumination, interior light, key reminder, light reminder, parking assist (rear view monitor), power slide door (LHD), rear fog light, taillight, wireless door lock control (LHD) |
| 24 | GAUGE NO.2 | 10 | ABS, automatic glare-resistant EC mirror, back-up light, ECT and A/T indicator, parking assist (rear view monitor), power slide door (LHD), seat belt warning |
| 25 | – | – | – |
| 26 | – | – | – |
| 27 | – | – | – |
| 28 | – | – | – |
| 29 | – | – | – |
| Relay | |||
| R1 | Dimmer | ||
| R2 | Headlight (HEAD) | ||
| R3 | – | ||
| R4 | Rear fog light (FOG RR) | ||
| R5 | – | ||
| R6 | Air conditioner compressor clutch (MG CLT) | ||
| R7 | PTC Heater (PTC NO.1) | ||
| R8 | – | ||
| R9 | PTC Heater (PTC NO.2) | ||
| R10 | Horn | ||
| R11 | Starter (ST) |
Fuse Boxes in the Engine Compartment
Fuse Boxes in the Engine Compartment
Fuse box location
Fuse box diagram
Assignment of the fuses in the Engine Compartment
| № | Name | Amp | Circuit |
|---|---|---|---|
| 1 | – | – | – |
| 2 | – | – | – |
| 3 | ST | 40 | Entry and start system |
| 4 | DOOR RR | 30 | Door closer (slide door), power slide door |
| 5 | A/PMP | 50 | 1TR-FE, 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system |
| 6 | ETCS | 10 | 1TR-FE, 2TR-FE: Electronic throttle control system, multiport fuel injection system/sequential multiport fuel injection system |
| 7 | EFI NO.2 | 10 | Multiport fuel injection system/sequential multiport fuel injection system |
| 8 | PSD RH | 25 | Power slide door |
| 9 | A/C NO.3 | 7.5 | Rear air conditioner |
| 10 | EFI NO.3 | 10 | 1TR-FE, 2TR-FE, 1KD-FTV: Multiport fuel injection system/sequential multiport fuel injection system |
| 11 | P/OUTLET | 15 | Power outlets |
| 12 | – | – | – |
| 13 | PTC NO.2 | 50 | PTC heater |
| 14 | PTC NO.1 | 50 | PTC heater |
| 15 | HTR FR | 40 | Front air conditioner, PTC heater |
| 16 | CLR RR | 30 | Rear air conditioner |
| 17 | DEF | 50 | Rear window defogger |
| 18 | MIR HTR | 15 | Outside rear view mirror defoggers |
| 19 | A/F HTR | 15 | Multiport fuel injection system/sequential multiport fuel injection system |
| 20 | EFI NO.1 | 25 | 1KD-FTV, 2KD-FTV, 5L-E: Multiport fuel injection system/sequential multiport fuel injection system |
| 21 | EFI NO.1 | 20 | 1TR-FE, 2TR-FE: Multiport fuel injection system/sequential multiport fuel injection system |
| 21 | EDU | 25 | 1KD-FTV, 2KD-FTV, 5L-E: Multiport fuel injection system/sequential multiport fuel injection system |
| 22 | – | – | – |
| 23 | P/I NO.1 | 80 | Passenger compartment additional fuse box |
| 24 | FAN NO.1 | 60 | Electric cooling fan |
| 25 | ALT | 150 | Charging system, “J/B”, “DEF”, “HTR FR”, “CLR RR”, “PTC NO.1”, “PTC NO.2” fuses |
| 26 | J/B | 100 | Passenger compartment fuse box |
| 27 | FAN NO.2 | 60 | Electric cooling fan |
| 28 | GLOW | 80 | 1KD-FTV, 2KD-FTV, 5L-E: Engine glow system |
| 29 | P/I NO.2 | 60 | “A/F HTR”, “EFI NO.1”, “EDU” fuses |
| 30 | – | – | – |
| Relay | |||
| R1 | Rear air conditioner (CLR RR) | ||
| R2 | Electric cooling fan (FAN NO.1) | ||
| R3 | Electric cooling fan (FAN NO.2) | ||
| R4 | Rear window defogger (DEF) | ||
| R5 | 1KD-FTV, 2KD-FTV, 5L-E: Engine glow system (GLOW) | ||
| R6 | 1KD-FTV, 2KD-FTV, 5L-E: – | ||
| R7 | 1KD-FTV, 2KD-FTV, 5L-E: – |
Additional Fuse Box
Engine Compartment Additional Fuse Box
| № | Name | Amp | Circuit |
|---|---|---|---|
| 1 | ABS SOL | 25 | ABS |
| 2 | HORN | 15 | Horn |
| 3 | ALT-S | 7.5 | Charging |
| 4 | DEF | 30 | Rear window defogger |
| 5 | RADIO | 15 | Audio system |
| 6 | DOME NO.2 | 10 | Interior light |
| 7 | DOME NO.1 | 10 | ABS, back-up light, clock, combination meter, daytime running light, multiport fuel injection system/sequential multiport fuel injection system, entry and start system, escape hammer buzzer system, front air conditioner, headlight (LED), headlight beam level control (automatic), illumination, interior light, key reminder light reminder, power slide door, PTC heater (1KD-FTV, 2KD-FTV), seat belt warning, SRS, taillight, turn signal and hazard warning light, wireless door lock control |
| 8 | D/C CUT | 30 | “RADIO1, “DOME NO.1”, “DOME NO.2” fuses |
| 9 | AM2 | 7.5 | Door closer (slide door),entry and start system, power slide door |
| 10 | TVSS | 15 | Power source |
| 11 | TRN&HAZ | 15 | Turn signal and hazard warning light, clock, combination meter |
| 12 | STRG LOCK | 10 | Entry and start system |
| 13 | PSD LH | 25 | Power slide door |
| 14 | ECU-B | 10 | Engine immobiliser system, entry and start system, front air conditioner, power slide door, PTC heater (1KD-FTV, 2KD-FTV), wireless door lock control |
| 15 | HEAD | 40 | Headlight (halogen), automatic light control, headlight beam level control (manual) |
| 16 | DOOR R/L | 30 | Door closer (slide door), power slide door |
| 17 | DOOR BK | 30 | Door closer (back door) |
| 18 | ABS MTR | 40 | ABS |
| 19 | AM2 | 30 | Multiport fuel injection system/sequential multiport fuel injection system |
