In this article, we consider the second-generation Ford Galaxy and first-generation Ford S-MAX, produced from 2006 to 2015. Here you will find fuse box diagrams of Ford Galaxy and S-MAX 2006, 2007, 2008, 2009, 2010, 2011, 2012, 2013 and 2014, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
See other Ford S-MAX / Galaxy:
Fuse Layout Ford S-MAX and Ford Galaxy (2006-2014)
Contents
Cigar lighter (power outlet) fuses: F7 (Cigar lighter) in the Instrument panel fuse box and FA6 (Auxiliary power socket) in the load compartment fuse box.
Table of Contents
Passenger Compartment Fuse Box
Passenger Compartment Fuse Box
Fuse Box Location
The fuse panel is located below the glove compartment (Pinch the retaining clips to release the cover, remove the cover, turn the knob through 90 degrees and release the fuse box from the retaining bracket, lower the fuse box cover and pull it towards you).
Fuse Box Diagram
Assignment of the fuses in the instrument panel
| № | Amp | Description |
|---|---|---|
| F1 | 7.5A | Steering wheel module |
| F2 | 5A | Cluster |
| F3 | 10A | Interior lamps |
| F4 | 5A | Engine immobiliser |
| F5 | 7.5A | Adaptive cruise control (ACC) |
| F6 | 5A | Rain sensor |
| F7 | 20A | Cigar lighter |
| F8 | 10A | Fuel filler flap unlock supply |
| F9 | 15A | Windscreen washers – rear |
| F10 | 15A | Windscreen washers – front |
| F11 | 10A | Luggage compartment release supply |
| F12 | 10A | Fuel filler flap lock supply |
| F13 | 20A | Fuel pump |
| F13 | 7.5A | Fuel pump (2.2L Duratorq-TDCi Stage V) |
| F14 | 5A | Remote frequency receiver, Interior motion sensor |
| F15 | 5A | Ignition switch |
| F16 | 5A | Battery backup sounder (alarm system), OBD II (board computer diagnostics) |
| F17 | 5A | Steering wheel vibration actuator |
| F18 | 10A | SRS (airbag) supply |
| F19 | 7.5A | ABS, yaw rate sensor (ESP), electric parking brake (EPB), accelerator pedal supply |
| F20 | 7.5A | Electronic feed, electronic fuse, Auto-dimming mirror, lane departure warning |
| F21 | 15A | Radio supply |
| F22 | 5A | Brake lamp switch |
| F23 | 20A | Sunroof |
| F24 | 5A | Climate Control Module and Steering Column Unit supply |
Engine Compartment Fuse Box
Engine Compartment Fuse Box
Fuse Box Location
Fuse Box Diagram
Assignment of the fuses in the engine compartment
| № | Amp | Description |
|---|---|---|
| F1 | 10A or 15A | Transmission control module (AWF21 – 10A; MPS6 – 15A) |
| F2 | 5A | Glow plug monitoring (diesel engines) |
| F2 | 5A | Vaporiser glow plug monitoring (2.0L Duratorq-TDCi Stage V and 2.2L Duratorq-TDCi Stage V) |
| F3 | 70A | Engine cooling fan – twin fan (2.3L Duratec-HE and 2.2L Duratorq-TDCi automatic) |
| F3 | 80A | Electric hydraulic power steering (EHPAS) (1.6L EcoBoost SCTi, 2.0L EcoBoost SCTi, 1.6L Duratorq-TDCi Stage V and 2.0L Duratorq-TDCi Stage V) |
| F4 | 60A | Glow plugs |
| F5 | 60A | Engine cooling fan (1.6L Duratorq-TDCi, 2.0L Duratorq-TDCi, 2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi manual, 2.0L Duratec-HE, 2.3L Duratec-HE and 2.0L EcoBoost SCTi) |
| F5 | 70A | Engine cooling fan – twin fan (1.6L EcoBoost SCTi) |
| F6 | 7.5A | HEGO sensor (1.6L Duratorq-TDCi) |
| F6 | 10A | HEGO sensor, CMS Sensor, Oxygen Sensor (engine management) |
| F6 | 20A | Vaporiser glow plug (2.0L Duratorq-TDCi Stage V and 2.2L Duratorq-TDCi Stage V) |
| F7 | 5A | Relay coils |
| F8 | 10A | Powertrain control module, fuel metering unit, MAF sensor, fuel rail pressure control valve (engine management) |
| F8 | 20A | Powertrain control module (2.0L EcoBoost SCTi and 2.0L Duratorq-TDCi Stage V) |
| F8 | 15A | Powertrain control module (1.6L EcoBoost SCTi, 1.6L Duratorq-TDCi and 2.2L Duratorq-TDCi Stage V) |
| F9 | 10A | MAF Sensor, Fuel Injectors (engine management) |
| F9 | 5A | Fuel pump vaporiser (2.0L Duratorq-TDCi Stage V) |
| F9 | 7.5A | MAF Sensor, EGR bypass Valve, Fuel pump vaporiser (2.2L Duratorq-TDCi Stage V) (engine management) |
| F9 | 7.5A | Degas valve, TMAF sensor, active grille shutter, bypass valve, relay coil, auxiliary run on water pump (1.6L EcoBoost SCTi) |
| F10 | 10A | Engine control module (2.0L Duratorq-TDCi) |
| F10 | 7.5A | Auxiliary run on, water pump (1.6L EcoBoost SCTi) |
| F11 | 10A | PCV Valve, VCV Valve, Water in Fuel Sensor, Sonic Purge Valve, Swirl Control Valve, Variable Intake Valve, EGR Valve, IVVT Oil Control Valve (engine management). T.MAF sensor, variable exhaust timing valve, active grille shutter, cannister purge valve. turbo control valve, wastegate valve (engine management). |
| F11 | 10A | Turbo control valve, MAF sensor, active grille shutter, EGR valve, VCV valve (1.6L Duratorq-TDCi) |
| F11 | 5A | MAF sensor, water in fuel sensor, active grille shutter, inlet metering valve (2.0L Duratorq-TDCi Stage V) |
| F11 | 7.5A | Fuel rail pressure, fuel metering unit, active grille shutter (2.2L Duratorq-TDCi Stage V) |
| F11 | 10A | Turbo control valve, variable intake timing valve, variable exhaust timing valve, cannister purge valve, electrical bypass valve (1.6L EcoBoost SCTi) |
| F12 | 10A | Coil on Plug; Canister Purge Valve, Power Steering Pressure Switch (engine management) |
| F12 | 10A | EGR throttle, variable turbo control (2.0L Duratorq-TDCi) |
| F12 | 5A | Relay coils (2.0L Duratorq-TDCi Stage V, 2.2L Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi) |
| F12 | 15A | Ignition coils (1.6L EcoBoost SCTi and 2.0L EcoBoost SCTi) |
| F13 | 15A | Air conditioning |
| F14 | 15A | Diesel filter heater (2.0L Duratorq-TDCi, 2.0L Duratorq-TDCi Stage V and 1.6L Duratorq-TDCi) |
| F14 | 10A | HEGO sensors (2.2L Duratorq-TDCi Stage V) |
| F15 | 40A | Starter relay |
| F16 | 80A | Diesel auxiliary heater (PTC) |
| F17 | 60A | Central fuse box supply A |
| F18 | 60A | Central fuse box supply B |
| F19 | 60A | Rear fuse box supply C |
| F20 | 60A | Rear fuse box supply D |
| F21 | 30A | VQM/non VQM: Cluster/Audio/AC/FLR |
| F22 | 30A | Windscreen wiper module |
| F23 | 25A | Heated rear window |
| F24 | 30A | Headlamp washer |
| F25 | 30A | ABS valves |
| F26 | 40A | ABS pump |
| F27 | 25A | Fuel fired heater |
| F28 | 40A | Heater blower |
| F29 | – | Not used |
| F30 | 5A | ABS 30 feed |
| F31 | 15A | Horn |
| F32 | 5A | Fuel fired heater – remote control |
| F33 | 5A | Light switch module, engine compartment fuse box coils |
| F34 | 40A | Heated windscreen (left-hand side) |
| F35 | 40A | Heated windscreen (right-hand side) |
| F36 | 15A | Rear wiper 15 feed |
| F37 | 7.5A | Heated front washer jets/FLR + FSM KL15 |
| F38 | 10A | PCM/TCM/EHPAS 15 feed |
| F39 | 15A | Adaptive front lighting system (AFS) |
| F40 | 5A | Headlamp levelling/AFS module |
| F41 | 20A | Instrument panel |
| F42 | 5A | Cluster IP |
| F43 | 15A | Audio/BVC module/DAB module |
| F44 | 5A | Automatic AC/Manual AC |
| F45 | 5A | FLR (Start Stop) |
Luggage Compartment Fuse Box
Luggage Compartment Fuse Box
Fuse Box Location
It is located behind the cover on the left side of the rear compartment.
Fuse Box Diagram
Assignment of the fuses in the load compartment
| № | Amp | Description |
|---|---|---|
| FA1 | 25A | Door module (left-hand front) (window up/down, central locking, electric folding mirror, heated mirror) |
| FA2 | 25A | Door module (right-hand front) (window up/down, central locking, electric folding mirror, heated mirror) |
| FA3 | 25A | Door module (left-hand rear) (window up/down) |
| FA4 | 25A | Door module (right-hand rear) (window up/down) |
| FA5 | 10A | Rear locking (without rear door modules) |
| FA6 | 15A | Auxiliary power socket |
| FA7 | 5A | Relay coils |
| FA8 | 20A | Keyless vehicle module |
| FA9 | 5A | Relay coils VQM (Start Stop) |
| FA10 | – | Not used |
| FA11 | 20A | Accessories, trailer module |
| FA12 | 30A | Electric driver’s seat |
| FB1 | 15A | Sunblind system |
| FB2 | 15A | Suspension module |
| FB3 | 15A | Heated driver’s seat |
| FB4 | 15A | Heated front passenger seat |
| FB5 | – | Not used |
| FB6 | 10A | Rear climate control |
| FB7 | – | Not used |
| FB8 | 5A | Parking aid, BLIS |
| FB9 | 30A | Electric front passenger seat |
| FB10 | 10A | Anti-theft alarm horn |
| FB11 | – | Not used |
| FB12 | – | Not used |
| FC1 | 7.5A | Electric rear quarter windows |
| FC2 | 30A | Electric parking brake (EPB) |
| FC3 | 30A | Electric parking brake (EPB) |
| FC4 | 10A | Rear air conditioning |
| FC5 | 20A | Keyless vehicle |
| FC6 | 20A | Rear air conditioning blower |
| FC7 | 5A | Seat memory function module |
| FC8 | 7.5A | Rear seat entertainment/CD Changer |
| FC9 | 20A | Audio amplifier |
| FC10 | 10A | Sony audiophile |
| FC11 | – | Not used |
| FC12 | – | Not used |
