Categories: Ford

Ford Expedition (U222; 2003-2006) fuses and relays

In this article, we consider the second-generation Ford Expedition (U222), produced from 2003 to 2006. Here you will find fuse box diagrams of Ford Expedition 2003, 2004, 2005 and 2006, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

See other Ford Expedition:

Ford Expedition (UN93; 1997-2002)…>>

Ford Expedition (U324; 2007-2014)…>>

Ford Expedition (U324; 2015-2017)…>>

Ford Expedition (U553; 2018-..)…>>

Fuse Layout Ford Expedition 2003-2006

Contents

Cigar lighter (power outlet) fuses in the Ford Expedition are the fuses №37 (Cargo area power point), №39 (Instrument panel or floor console power point, Rear console power point) and №41 (Cigar lighter) in the Passenger compartment fuse box.

Table of Contents

Fuse box location

Passenger compartment fuse panel

The fuse panel is located under the right-hand side of the instrument panel behind the cover

To remove the trim panel for access to the fusebox, pull the panel toward you and swing it out away from the side and remove it.
To reinstall it, line up the tabs with the grooves on the panel, then push it shut.

To remove the fuse box cover, place a finger behind the PULL tab and your thumb above the PULL tab as shown in the illustration, then pull the cover off.
To reinstall the fusebox cover, place the top part of the cover on the fuse panel, then push the bottom part of the cover until you hear it click shut. Gently pull on the cover to make sure it is seated properly.

Fuse box diagrams

2003

Assignment of the fuses in the Power distribution box (2003)

№	Amp Rating	Passenger Compartment Fuse Panel Description
1	10 A*	Front wiper motor, Instrument cluster, Rear wiper motor, Tire Pressure Monitoring System (TPMS)
2	20 A*	Turn signal flasher, Stoplamp switch, Hazard flasher, IVD (AdvanceTrac) stoplamps relay
3	7.5A*	Power mirrors, Memory seat switch, Memory seat module
4	10 A*	DVD player, Rear seat audio controls, CDDJ
5	7.5A*	Powertrain Control Module (PCM) (KA power), SC deactivate switch, Manual climate control mode switch, Stoplamp switch, Brake-shift interlock (BSI) solenoid, EATC control head, BSM module, Speed control servo, 3rd row seat relay
6	15 A*	Headlamp switch, Parklamps, License plate lamps, Trailer tow’ electric brake controller, BSM parklamps relay
7	7.5A*	Radio
8	10 A*	Rear window defroster switch, Heated mirrors
9	10 A*	Alternator
10	20 A*	Back-up lamps, Back-up lamp relay, Trailer tow’ parklamp relay
11	10 A*	A/C clutch relay, 4×4 IWE solenoid
12	10 A*	Speed control servo, Speed control
13	10 A*	EATC control head, Manual climate control head
14	15 A*	Climate control blend door actuator, Daytime Running Lamps (DRL) relays, Digital Transmission Range Sensor (DTRS) back-up lamp
15	5A*	AdvanceTrac® switch, Instrument cluster
16	10 A*	ABS module
17	15 A*	Foglamps
18	10 A*	Electrochromic mirror, Auxiliary A/C, Climate-controlled seats module, Temperature solenoid, Turn signal flasher, Sunload sensor, Electronic park brake relay coil
19	10 A*	Restraints Control Module (RCM)
20	30A*	Air suspension module (air spring solenoids and height sensors), 4×4 module
21	15 A*	Instrument cluster (interior lamps), Interior lamps, Electronic park brake relay, Tire Pressure Monitoring System (TPMS)
22	10 A*	Door lock switch illumination, Moonroof switch illumination, Radio (delayed accessory signal), Flip window switch
23	10 A*	RH low beam
24	15 A*	Battery saver relay, Front map/Dome lamp, 2nd row dome/map lamp, Glove compartment lamp, Cargo lamp, Rail lamps, Vanity mirror lamps, Underhood lamp
25	10 A*	LH low beam
26	20 A*	Horn relay, Horns
27	5A*	Compass, Reverse sensing system module, Brake shift interlock (BSI) solenoid, Overdrive cancel switch, Air suspension module (Run/Start sense)
28	5A*	SecuriLock transceiver
29	30A*	Trailer tow electric brake controller
30	30A*	BSM (door locks), Liftgate glass release relay, Liftgate glass release motor, Door/Liftgate locks, Parklamps relay (BSM), Headlamps relay (BSM), Door lock/Unlock relay (BSM)
31	25A*	Radio
32	15 A*	CMS, Transmission solenoids
33	20 A*	Canister vent solenoid, EVR CC, HEGOs, VMV solenoid, IMTV solenoid, A/C clutch relay coil
34	20 A*	PCM, Fuel injectors, Idle air control (IAC) solenoid, Mass air flow sensor
35	20 A*	Instrument cluster high beam indicator, High beam headlamps
36	10 A*	Trailer tow right turn lamp
37	20 A*	Cargo area power point
38	25A*	Rear wiper motor, Washer pump (rear window wash)
39	20A*	Instrument panel or floor console power point, Rear console power point
40	20 A*	Headlamp switch, High beam relay coil, LH low beam fuse # 25, LH low beam fuse # 23, BSM (autolamps headlamp relay), DRL
41	20 A*	Cigar lighter, OBD II Connector
42	10 A*	Trailer tow left turn lamp
101	30A**	Starter relay, Starter solenoid
102	30A**	Ignition switch, Starter solenoid
103	30A**	ABS module (pump motor)
104	30A**	LH 3rd row power seat
105	30A**	Spare
106	30A**	Trailer tow battery charge relay
107	30A**	Auxiliary blower relay, Auxiliary blower motor
108	30A**	Power passenger seat switch, Passenger power lumbar switch
109	30A**	Driver seat motor switch, Driver lumbar switch, Adjustable pedal switch, Memory module
110	30A**	Spare
111	50A**	Air suspension solid state relay, Air suspension compressor
112	30A**	ABS module (valves)
113	30A**	Front wiper motor, Front washer pump
114	40A**	Rear window defrost relay, Heated mirrors (Fuse #
115	30A**	4×4 module, Transfer case shift motor
116	40A**	Front blower relay, Front blower motor
117	30A**	RH 3rd row’ power seat
118	30A**	Driver and passenger climate control seat module
401	30A**	Power window’ circuit breaker, Mam window switch, Window motors, Window switches, Moonroof module
R01	Starter relay	Starter motor solenoid
R02	Delayed accessory relay	Fuse # 22, CB # 401, Power windows, Switch backlighting, Radio, Moonroof, Flip windows
R03	Hi-beam relay	Fuse # 35, Hi-beam headlamps, Hi-beam indicator, DRL relays
R04	Rear window defroster relay	Fuse # 8 (heated mirrors), Rear window defroster
R05	T/T battery charge relay	TT 7 wire connector, Battery charge
R06	Front blower relay	Blower motor, Blower motor speed control (EATC)
R201	T/T park lamp relay	Trailer tow park lamps feed
R202	Fog lamp relay	Front fog lamps
R203	PCM relay	Fuse # 32, Fuse # 33, Fuse # 34, Fuel pump relay, PCM solenoids and sensors
R301	T/T back-up lamp relay	Back-up lamps, TT connector (back-up lamps), Electrochromic mirror
R302	Speed control relay	Electric cooling fan clutch, Speed control servo
R303	Fuel pump relay	Fuel pump shut-off switch, PCM fuel pump monitor, Fuel pump
R304	Battery saver relay	Rail lamps, Vanity mirror lamps, Dome lamp, Glove box lamp, Instrument cluster
R305	Horn relay	Dual note horn
		* Mini Fuses ** Maxi Fuses

2004

Assignment of the fuses in the Power distribution box (2004)

№	Amp Rating	Passenger Compartment Fuse Panel Description
1	10 A*	Run/Accessory – Front wiper motor, Instrument cluster, Rear wiper motor, Tire Pressure Monitor System (TPMS) module
2	20 A*	Turn signal/Hazard flasher, Stoplamp switch, IVD (AdvanceTrac) stoplamps relay, Stoplamps, Center high-mount stop light (CHMSL), Turn signal lamps
3	7.5 A*	Power mirror switch, Power mirrors (non-memory), Driver seat switch (memory), Memory module (logic power)
4	15 A*	DVD player, Rear seat audio controls, CDDJ (navigation radio)
5	7.5 A*	Powertrain Control Module (PCM) (KA power), Speed control deactivation switch, Manual climate control mode switch, Stoplamp switch, Brake-shift interlock (BSI) solenoid, EATC control head, Body Security Module (BSM) (KA power), Speed control servo, 3rd row seat relay coils, SecuriLock LED
6	15 A*	Headlamp switch (parklamps and switch backlight feed), Parklamps, License plate lamps, Foglamp relay coil, Trailer tow electric brake controller (illumination), BSM (autolamp, parklamps) Foglamp indicator
7	7.5 A*	Radio (start signal)
8	10 A*	Rear window defroster switch, Rear window defroster indicator (climate control head), Heated outside mirrors
9	—	Not used
10	20 A*	Trailer tow back-up lamps relay, Trailer tow 7-wire connector (back-up lamps), Trailer tow parklamp relay, Trailer tow 7- and 4-pin connectors (parklamps)
11	10 A*	A/C compressor clutch relay, A/C compressor clutch solenoid, Air suspension compressor relay, 4×4 Integrated Wheel Ends (IWE) solenoid
12	10 A*	Speed control servo, Speed control relay
13	10 A*	Manual climate control mode switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C compressor thermistor, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow’ batteiy charge relay coil
14	10 A*	Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow’ back-up lamps relay coil, Electrochromatic mirror, Navigation radio, Manual A/C blend door actuator
15	5A*	AdvanceTrac® switch, Instrument cluster (Run/Start feed)
16	10 A*	ABS/AdvanceTrac® module (Run/Start feed)
17	15 A*	Foglamps
18	10 A*	Auxiliary A/C temperature blend door actuator, Auxiliary A/C front auxiliary control, Turn signal flasher, Electrochromatic mirror, Auxiliary mode motor, Climate controlled seat modules
19	10 A*	Restraints Control Module (RCM)
20	30A*	Air suspension module (air spring solenoids and height sensors), 4×4 module
21	15 A*	Instrument cluster (B+), Interior (courtesy) lamps, Puddle lamps (outside mirrors), Tire Pressure Monitoring System (TPMS) module
22	10 A*	Moonroof switch illumination, Radio (delayed accessory feed), Flip window swatch, Flip window motors, EHAM antenna amplifier (navigation radio)
23	10 A*	RH low beam
24	15 A*	Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power
25	10 A*	LH low beam
26	20 A*	Horn relay, Horns
27	5A*	Compass module, Reverse sensing system module, Brake shift interlock (BSI) solenoid, Overdrive cancel switch, Air suspension module (Run/Start sense)
28	5A*	PCM relay coil, Speed control relay coil, SecuriLock transceiver
29	30A*	Trailer tow electric brake controller, Trailer tow 7-wire connector (electric brake)
30	30A*	BSM (door locks, liftgate glass release relay), Liftgate glass release motor, Door/Liftgate lock motors
31	20 A*	Radio (B+), Subwoofer
32	15 A*	Catalyst Monitor Sensors (CMS), Transmission solenoids
33	20 A*	Canister vent solenoid, HEGO sensors, VMV solenoid, Intake Manifold Tuning Valve (IMTV-4.6L engine) solenoid, A/C compressor clutch relay coil, EGR vacuum regulator (EVR) solenoid
34	20 A*	PCM, Fuel injectors, Fuel pump relay, Fuel pump shut-off switch, Fuel pump motor, Idle air control (IAC) solenoid, Mass Air Flow (MAF) sensor
35	20 A*	Instrument cluster high beam indicator, High beam headlamps
36	10 A*	Trailer tow right turn/stop lamps
37	20 A*	Cargo area power point
38	25A*	Rear wiper motor, Washer pump (rear window wash)
39	20 A*	Console power points (front and rear of console), Instrument panel power point (bench seat)
40	20 A*	DRL relays, DRL foglamps, DRL headlamp relay coil, Headlamp switch (headlamps), Multifunction switch (flash-to-pass), BSM (autolamp headlamps relay), High beam relay coil, Fuse 25 (LH low beam), Fuse 23 (RH low beam)
41	20 A*	Cigar lighter, OBD II diagnostic connector
42	10 A*	Trailer tow left turn/stop lamps
101	30A**	Starter motor relay, Starter motor solenoid
102	30A**	Ignition switch power
103	30A**	ABS/AdvanceTrac @ module (pump motor)
104	30A**	LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor
105	40A**	Spare
106	30A**	Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge)
107	30A**	Auxiliary A/C blower relay, Auxiliary A/C blower motor
108	30A**	Passenger seat motor switch
109	30A**	Driver seat motor switch (non-memory), Memory module, Power memory mirrors, Adjustable pedals switch and motor
110	30A**	Spare
111	50A**	Air suspension compressor, Air suspension compressor relay
112	30A**	ABS/AdvanceTrac® module (valves)
113	30A**	Front wiper motor, Washer pump (windshield wash)
114	40A**	Rear window defroster relay, Rear window defroster grid, Heated mirrors (Fuse
115	30A**	4×4 module, Transfer case shift motor
116	40A**	Front blower motor relay, Front blower motor
117	30A**	RH 3rd row seat relay, RH 3rd row seat switch, RH 3rd row seat motor
118	30A**	Driver and passenger climate control seat module
401	30A**	Power windows (circuit breaker), Main window switch, Window motors, Window switches, Moonroof module
R01	Starter relay	Starter motor solenoid
R02	Delayed accessoiy relay	Fuse 22, CB 401, Power windows, Switch backlighting, Radio, Moonroof, Flip windows, DVD, Navigation antenna amplifier
R03	Hi-beam relay	Fuse # 35, Hi-beam headlamps, Hi-beam indicator
R04	Rear window defrost relay	Fuse 8 (heated mirrors), Rear window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head)
R05	Trailer tow battery charge relay	Trailer tow 7-wire connector (battery charge)
R06	Front blower relay	Front blower motor
R201	Trailer tow park lamp relay	Trailer tow 7-wire and 4-wire connectors (park lamps)
R202	Foglamp relay	Front foglamps
R203	PCM relay	Fuse 32, Fuse 33, Fuse 34, Fuel pump relay, Fuel pump, PCM solenoids and sensors
R301	Trailer tow back-up lamp relay	Trailer tow 7-wire connector (back-up lamps)
R302	Speed control relay	Speed control servo
R303	Fuel pump relay	Fuel pump shut-off switch, PCM (fuel pump monitor), Fuel pump
R304	Battery saver relay	Roof rail lamps, Vanity mirror lamps, Map/Dome lamp, Glove box lamp, Cargo area lamp, Outside mirror puddle lamps, Instrument cluster (interior lamps)
R305	Horn relay	Dual note horn
		* Mini Fuses ** Maxi Fuses
		Note: Relays R301–R305 are not serviceable components; see your dealer or a qualified technician for assistance.

2005, 2006

Assignment of the fuses in the Power distribution box (2005, 2006)

№	Amp Rating	Passenger Compartment Fuse Panel Description
1	7.5 A*	Run/Accessory – Front wiper motor, Instrument cluster, Rear wiper motor
2	20 A*	Turn signal/Hazard flasher, Stoplamp switch, Stoplamps, Center high-mount stop light (CHMSL), Turn signal lamps
3	7.5 A*	Power mirror switch, Power mirrors (non-memory), Driver seat switch (memory), Memory module (logic power)
4	15 A*	DVD player, Rear seat audio controls, CDDJ (navigation radio)
5	7.5 A*	Powertrain Control Module (PCM) (KA power), Speed control deactivation switch, Manual climate control mode switch, Stoplamp switch, Brake-shift interlock (BSI) solenoid, EATC control head, Body Security Module (BSM) (KA power), 3rd row seat relay coils, SecuriLock LED
6	15 A*	Headlamp switch (parklamps and switch backlight feed), Parklamps, License plate lamps, Foglamp relay coil, Trailer tow electric brake controller (illumination), BSM (autolamp, parklamps) Foglamp indicator
7	5A*	Radio (start signal)
8	10 A*	Rear window defroster switch, Rear window defroster indicator (climate control head), Heated outside mirrors
9	—	Not used
10	20 A*	Trailer tow back-up lamps relay, Trailer tow 7-wire connector (back-up lamps), Trailer tow parklamp relay, Trailer tow 7- and 4-pin connectors (parklamps)
11	10 A*	A/C compressor clutch relay, A/C compressor clutch solenoid, 4×4 Integrated Wheel Ends (IWE) solenoid
12	15 A*	Fuel pump relay, Fuel pump shut-off switch, Fuel pump driver module, Fuel pump motor
13	10 A*	Manual climate control mode switch, Rear window defroster relay coil, A/C refrigerant containment switch, A/C de-icing switch, A/C low pressure switch, DEATC control head, DEATC solenoids, DEATC blower control, Trailer tow battery charge relay coil
14	10 A*	Daytime Running Lamps (DRL) ignition relay coil, Digital Transmission Range Sensor (DTRS) back-up lamps, Trailer tow’ back-up lamps relay coil, Electrochromatic mirror, Navigation radio, Manual A/C blend door actuator
15	5A*	AdvanceTrac® with RSC switch, Instrument cluster (Run/Start feed)
16	10 A*	ABS/AdvanceTrac® with RSC module (Run/Start feed)
17	15 A*	Foglamps
18	10 A*	Auxiliary A/C temperature blend door actuator, Auxiliary A/C front auxiliary control, Turn signal flasher, Electrochromatic mirror, Auxiliary mode motor
19	10 A*	Restraints Control Module (RCM)
20	30A*	BSM (door locks, liftgate glass release relay), Liftgate glass release motor, Door/Liftgate lock motors
21	15 A*	Instrument cluster (B+), Interior (courtesy) lamps, Puddle lamps (outside mirrors)
22	10 A*	Moonroof switch illumination, Radio (delayed accessory feed), Flip window swatch, Flip window motors, EHAM antenna amplifier (navigation radio)
23	10 A*	RH low beam
24	15 A*	Interior demand lamps (front map/dome lamp, 2nd row dome/map lamp, glove compartment lamp, cargo lamp, roof rail lamps, vanity mirror lamps), Battery saver relay coil, Battery saver relay power, Heated Positive Crankcase Ventilation (PCV) valve
25	10 A*	LH low beam
26	20 A*	Horn relay, Horns
27	5A*	Compass module, Reverse sensing system module, Brake shift interlock solenoid, Overdrive cancel swatch, Air suspension module (Run/Start sense)
28	5A*	PCM relay coil, SecuriLock transceiver, Heated PCV valve relay coil
29	30A*	Trailer tow electric brake controller, Trailer tow 7-wire connector (electric brake)
30	25A*	Air suspension module (air spring solenoids and height sensors), PCM (4×4 transfer case clutch)
31	20 A*	Radio (B+), Subwoofer
32	15 A*	Catalyst Monitor Sensors (CMS), Transmission solenoids, Canister vent solenoid, HEGO sensors, VMV solenoid, A/C compressor clutch relay coil, CMCV, VCT actuators
33	—	Not used
34	15 A*	PCM, Fuel injectors, Mass Air Flow (MAF) sensor
35	20 A*	Instrument cluster high beam indicator, High beam headlamps
36	10 A*	Trailer tow right turn/stop lamps
37	20 A*	Cargo area power point
38	25A*	Rear wiper motor, Washer pump (rear window wash)
39	20 A*	Console power points (front and rear of console), Instrument panel power point (bench seat)
40	20 A*	DRL relays, DRL foglamps, DRL headlamp relay coil, Headlamp switch (headlamps), Multifunction switch (flash-to-pass), BSM (autolamp headlamps relay), High beam relay coil, Fuse 25 (LH low beam), Fuse 23 (RH low beam)
41	20 A*	Cigarette lighter, OBD II diagnostic connector
42	10 A*	Trailer tow left turn/stop lamps
101	30A**	Starter motor relay, Starter motor solenoid
102	30A**	Ignition switch power
103	30A**	ABS/AdvanceTrac® with RSC module (pump motor)
104	30A**	LH 3rd row seat relay, LH 3rd row seat switch, LH 3rd row seat motor
105	30A**	Spare
106	30A**	Trailer tow battery charge relay, Trailer tow 7-way connector (battery charge)
107	30A**	Auxiliary A/C blower relay, Auxiliary A/C blower motor
108	30A**	Passenger seat motor switch
109	30A**	Driver seat motor switch (non-memory), Memory module, Power memory mirrors, Adjustable pedals switch and motor
110	30A**	Spare
111	50A**	Air suspension compressor, Air suspension compressor relay
112	30A**	ABS/AdvanceTrac#k8SjZc9Dxk with RSC module (valves)
113	30A**	Front wiper motor, Washer pump (windshield wash)
114	40A**	Rear window defroster relay, Rear window defroster grid, Heated mirrors (Fuse
115	30A**	Transfer case shift motor, 4×4 relays
116	40A**	Front blower motor relay, Front blower motor
117	30A**	RH 3rd row seat relay, RH 3rd row seat switch, RH 3rd row seat motor
118	30A**	Driver and passenger climate control seat module
401	30A CB (circuit breaker)	Power windows (circuit breaker), Main window switch, Window motors, Window switches, Moonroof module
R01	Starter relay	Starter motor solenoid
R02	Delayed accessoiy relay	Fuse 22, CB 401, Power windows, Switch backlighting, Radio, Moonroof, Flip windows, Navigation antenna amplifier
R03	Hi-beam relay	Fuse # 35, Hi-beam headlamps, Hi-beam indicator
R04	Rear window defrost relay	Fuse 8 (heated mirrors), Rear window defroster, Heated outside mirrors, Rear window defroster indicator (climate control head)
R05	Trailer tow’ battery charge relay	Trailer tow 7-wire connector (battery charge)
R06	Front blower relay	Front blower motor
R201	Trailer tow park lamp relay	Trailer tow 7-wire and 4-wire connectors (park lamps)
R202	Foglamp relay	Front foglamps
R203	PCM relay	Fuse 32, Fuse 34, PCM solenoids and sensors
R301	Trailer tow back-up lamp relay	Trailer tow 7-wire connector (back-up lamps)
R302	Heated PCV valve relay	Heated PCV valve
R303	Fuel pump relay	Fuel pump shut-off switch, PCM (fuel pump monitor), Fuel pump, Fuel pump driver module
R304	Battery saver relay	Roof rail lamps, Vanity mirror lamps, Map/Dome lamp, Glove box lamp, Cargo area lamp, Outside mirror puddle lamps, Instrument cluster (interior lamps)
R305	Horn relay	Dual note horn
		* Mini Fuses ** Maxi Fuses
		Note: Relays R301–R305 are not serviceable components; see your dealer or a qualified technician for assistance.