The minivan Mercury Monterey was produced from 2004 to 2007. Here you will find fuse box diagrams of Mercury Monterey 2004, 2005, 2006 and 2007, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
Fuse Layout Mercury Monterey 2004-2007
Contents
Cigar lighter (power outlet) fuses in the Mercury Monterey are the fuses #57 (2004: Cigar lighter), #61 (2004: 3rd-row power point), #63 (2005-2007: Instrument panel power point, Cigar lighter) and #66 (2005-2007: 2nd-row seat power point, 3rd row power point) in the Engine Compartment Fuse Box.
Table of Contents
Instrument Panel Fuse Box
Instrument Panel Fuse Box
Fuse box location
The fuse panel is located below and to the left of the steering wheel by the brake pedal.
Fuse box diagram
Assignment of the fuses in the passenger compartment
| № | Protected components | Amp |
|---|---|---|
| 3 | Front wiper motor Run feed | 10 |
| 4 | B+ feed to outside mirrors | 5 |
| 5 | Vent window power feed/Radio feed | 20 |
| 6 | Driver door switch illumination/Passenger door switch illumination | 5 |
| 7 | Rear wiper Run feed | 10 |
| 8 | Cluster/Electronic Automatic Temperature Control (EATC) B+ feed, DVD | 10 |
| 9 | Passive Anti-theft System (PATS) LED feed | 10 |
| 10 | Auxiliary radio | 5 |
| 11 | Auxiliary climate control system/Power Liftgate Module/Left and right power sliding door module/Data Link Connector (DLC)/Clock B+ feeds | 5 |
| 12 | Brake-Shift Interlock (BSI) Run feed, Climate control system Run feed | 5 |
| 13 | Compass/Driver heated seat/Passenger heated seats/Reverse sensing system/Power Liftgate Module/Power sliding door Run feeds | 5 |
| 14 | Underhood fuse box Run feed, Front blower Run feed | 5 |
| 15 | Brake On-Off (BOO) switch B+ | 10 |
| 16 | Steering angle/Cluster/Power sliding door and power liftgate inhibit LED/Electrochromatic mirror Run/Start/Tire Pressure Monitoring System (TPMS) | 5 |
| 17 | Restraint Control Module (RCM)/Passenger Air bag Disable Indicator (PADI)/Passenger Occupant Detection System (PODS) Run/Start | 10 |
| 18 | Anti-lock Brake System (ABS) module/Brake pressure switch/Speed control Run/Start | 10 |
| 19 | PATS/Cluster/Air bag LED/Powertrain Control Module (PCM) relay Run/Start | 5 |
| 20 | Liftgate Start feed, Radio Start feed | 10 |
| 21 | Starter relay power START | 10 |
| Relays | ||
| 1 | Accessory delay relay 1 | |
| 2 | Accessory delay relay 2 |
Engine Compartment Fuse Box
Engine Compartment Fuse Box
Fuse box location
The fuse box is located in the engine compartment (on the driver’s side), under the cover
Fuse box diagram
Assignment of the fuses and relays in the engine compartment
| № | Protected components | Amp |
|---|---|---|
| 1 | Not used | — |
| 2 | Right cooling fan | 30 |
| 3 | Left cooling fan | 30 |
| 4 | Starter solenoid | 30 |
| 5 | Right-hand power sliding door | 30 |
| 6 | SJB accessory #2 (driver power window) | 30 |
| 7 | Auxiliary blower motor | 30 |
| 8 | Anti-lock Brake System (ABS) #2 (coil power) | 40 |
| 9 | Power liftgate | 30 |
| 10 | SJB accessory #1 (passenger window, radio, vent windows) | 30 |
| 11 | Left power seat/heated seat | 30 |
| 12 | ABS #1 (pump motor) | 40 |
| 13 | Rear defroster | 40 |
| 14 | Front climate control system blower motor | 30 |
| 15 | Right power seat/heated seat | 30 |
| 16 | Left-hand power sliding door | 30 |
| 40 | Engine #1 (A/C relay coil, IMRC, HEGO sensors, Canister purge, Transmission module, Canister vent (2004-2005)) | 15 |
| 41 | Horn | 25 |
| 42 | A/C clutch | 10 |
| 43 | Engine #2 (Cooling fan relays, Injectors, PCM, MAF sensor, IAC, Ignition coil, ESM) | 15 |
| 44 | Heated PCV | 10 |
| 45 | High beams | 15 |
| 46 | Trailer stop/turn lamps | 20 |
| 47 | Fuel pump, Fuel pump shut-off switch | 15 |
| 48 | Fog lamps | 15 |
| 49 | PCM KAP, Canister vent (2006-2007) | 10 |
| 50 | Alternator | 10 |
| 51 | Adjustable pedals (non-memory) or memory module | 10 |
| 52 | Trailer tow park lamps | 20 |
| 53 | Heated mirrors | 10 |
| 54 | Front wiper motor | 30 |
| 55 | Rear wiper motor | 25 |
| 56 | Premium sound radio | 30 |
| 57 | 2004: Cigar lighter | 20 |
| 58 | SJB #1 – Center High-Mounted Stop Lamp (CHMSL), License plate lamps, OBD II, Dome lamp, Auxiliary blend doors, Switch illumination (feeds F-8, F-9, F-10nd F-ll) | 30 |
| 59 | Radio (non-premium) | 20 |
| 60 | SJB #4 – Back-up lamps, Theft sounder (2004), Door locks | 30 |
| 61 | 2004: 3rd row power point | 20 |
| 62 | SJB #3 – Right comering/auxiliary lamps, Right low beam, Left front park/turn lamps, Left rear park/stop/turn lamps, Instrument panel courtesy lamps, Step well lamps, Left signal mirror, Clock, Cluster, Message center (SJB F-15), Switch illumination for: overhead console, DVD/Rear climate control system, Headlamp switch illumination, Climate control illumination | 30 |
| 63 | Instrument panel power point, Cigar lighter (2005-2007) | 20 |
| 64 | Ignition switch #1 feed | 20 |
| 65 | SJB #2 – Left cornering/auxiliary lamps, Left low beam, Right front park/turn lamps, Right rear park/stop/turn lamps, Puddle lamps, Mirror signals, Visors, 2nd and 3rd row lamps, Cargo lamp, Defroster indicator | 30 |
| 66 | 2nd row seat power point, 3rd row power point (2005-2007) | 20 |
| 67 | Ignition switch #2 feed | 20 |
| 70 | Not used | — |
| 71 | Not used | — |
| 72 | Not used | — |
| 73 | Not used | — |
| 74 | Not used | — |
| Relays | ||
| 20 | Powertrain Control Module (PCM) power | |
| 21 | Horn | |
| 22 | A/C clutch | |
| 23 | High beams | |
| 24 | Starter | |
| 25 | Fuel pump | |
| 26 | Fog lamps | |
| 27 | Not used | |
| 28 | Auxiliary blower | |
| 29 | Trailer park lamps | |
| 30 | Left trailer stop/turn lamps | |
| 31 | Right trailer stop/turn lamps | |
| 32 | Rear defroster | |
| Diodes | ||
| 75 | PCM | |
| 76 | A/C clutch |
Auxiliary relay box (cooling fans)
Auxiliary relay box (cooling fans)
The relay box is located in the engine compartment by the radiator.
Auxiliary Relay Box
| № | Protected components | Amp |
|---|---|---|
| 6 | Right-hand cooling fan motor (Vehicles with trailer tow package only) | 40 |
| 7 | Low-speed cooling fan circuit breaker (Vehicles with trailer tow package only) | 15 |
| 8 | Left-hand cooling fan motor (Vehicles with trailer tow package) | 40 |
| 8 | Low-speed cooling fan circuit breaker (Vehicles without trailer tow package) | 10 |
| Relays | ||
| 1 | Cooling fan relay #1 or #4 | |
| 2 | Cooling fan relay #2 or #5 | |
| 3 | Cooling fan relay #3 | |
| 4 | Cooling fan relay #4 or #1 | |
| 5 | Cooling fan relay #5 or #2 |
