In this article, we consider the sixth-generation Chevrolet Malibu, produced from 2004 to 2007. Here you will find fuse box diagrams of Chevrolet Malibu 2004, 2005, 2006 and 2007, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.
Fuse Layout Chevrolet Malibu 2004-2007
Contents
Cigar lighter (power outlet) fuses in the Chevrolet Malibu are the fuses №12 (Auxiliary Power 2) and №20 (Cigarette Lighter, Auxiliary Power Outlet) in the Luggage Compartment Fuse Box.
Table of Contents
Passenger Compartment Fuse Box
Fuse box location
It is located on the passenger side of the vehicle, on the lower portion of the instrument panel near the floor, behind the cover.
Fuse box diagram
Assignment of the fuses and relays in the Passenger Compartment
| Name | Usage |
|---|---|
| POWER MIRRORS | Power Mirrors |
| EPS | Electric Power Steering |
| RUN/CRANK | Cruise Control, Electronic Range Select, Driver Shift Control, Passenger Airbag Status Indicator |
| HVAC BLOWER HIGH (Relay) | Climate Control System |
| CLUSTER/ THEFT | Instrument Panel Cluster, Theft Deterrent System |
| ONSTAR | OnStar System |
| NOT INSTALLED | Not Used |
| AIRBAG (IGN) | Airbag System |
| HVAC CTRL (BATT) | Climate Control System |
| PEDAL | Adjustable Throttle and Brake Pedal |
| WIPER SW | Windshield Wiper/Washer Switch |
| IGN SENSOR | Ignition Switch |
| STR/WHL ILLUM | Steering Wheel Controls Backlighting |
| NOT INSTALLED | Not Used |
| RADIO | Audio System |
| INTERIOR LIGHTS | Overhead Lighting, Trunk/Cargo Lighting |
| REAR WIPER | Rear Wiper System/Washer Pump |
| HVAC CTRL (IGN) | Climate Control System |
| HVAC BLOWER | Climate Control System |
| DOOR LOCK | Automatic Door Lock System |
| ROOF/HEAT SEAT | Sunroof, Heated Seats, Automatic Dimming Rearview Mirror, Compass, Rear Wiper/Washer System |
| POWER WINDOWS | Power Window Switch |
| NOT INSTALLED | Not Used |
| NOT INSTALLED | Not Used |
| AIRBAG (BATT) | Airbag System |
| FUSE PULLER | Fuse Puller |
| SPARE FUSE HOLDER | Spare |
| SPARE FUSE HOLDER | Spare |
| SPARE FUSE HOLDER | Spare |
| SPARE FUSE HOLDER | Spare |
Engine Compartment Fuse Box
Fuse box location
It is located in the engine compartment (left-side), under the cover.
Fuse box diagram
Assignment of the fuses and relay in the Engine Compartment
| Name | Usage |
|---|---|
| 1 | Air Conditioning Clutch |
| 2 | Electronic Throttle Control |
| 3 | Engine Control Module (IGN 1) (V6) |
| 4 | Transmission |
| 5 | 2004-2005: Fuel Injectors |
| 6 | Emission 1 |
| 7 | Left Headlamp Low-Beam |
| 8 | Horn |
| 9 | Right Headlamp Low-Beam |
| 10 | Front Fog Lamps |
| 11 | Left Headlamp High-Beam |
| 12 | Right Headlamp High-Beam |
| 13 | Engine Control Module (BATT) (L4) |
| 14 | Windshield Wiper |
| 15 | Anti-lock Brake System |
| 16 | Engine Control Module (IGN 1) (L4) |
| 17 | Cooling Fan 1 |
| 18 | Cooling Fan 2 |
| 19 | Run Relay |
| 20 | IBCM 1 |
| 21 | IBCM (R/C) |
| 22 | Rear Electrical Center 1 |
| 23 | Rear Electrical Center 2 |
| 24 | Anti-lock Brake System |
| 25 | IBCM2 |
| 26 | Starter |
| 27 (DIODE) | Windshield Wiper |
| 41 | Electric Power Steering |
| 42 | Transaxle Control Module |
| 43 | Ignition Module |
| 44 | 2006-2007: Fuel Injectors |
| 45 | Rear Oxygen Sensors |
| 46 (Resistor) | Brake Lamp Diagnostic |
| 47 | Daytime Running Lamps |
| 51 | Engine Control Module (BATT) (V6) |
| Relays | |
| 28 | Cooling Fan 1 |
| 29 | Cooling Fan Mode Series/Parallel |
| 30 | Cooling Fan 2 |
| 31 | Starter |
| 32 | Run/Crank, Ignition |
| 33 | Powertrain |
| 34 | Air Conditioning Clutch |
| 35 | High-Beam Headlamps |
| 36 | Front Fog Lamps |
| 37 | Horn |
| 38 | Low-Beam Headlamps |
| 39 | Windshield Wiper 1 |
| 40 | Windshield Wiper 2 |
| 48 | Daytime Running Lamps |
Luggage Compartment Fuse Box
Fuse box location
Rear Compartment Fuse Block is located in the luggage compartment (on the left-side), behind the cover.
Fuse box diagram
Assignment of the fuses and relay in the Luggage Compartment
| Name | Usage |
|---|---|
| 1 | Not Used |
| 2 | Driver Seat Controls |
| 3 | Not Used |
| 4 (Resistor) | Driver Door Key Lock Cylinder / Not Used |
| 5 | Emission |
| 6 | Parklamps |
| 7 | Not Used |
| 8 | Not Used |
| 9 | Not Used |
| 10 | Sunroof Controls |
| 11 | Not Used |
| 12 | Auxiliary Power 2 |
| 13 | Not Used |
| 14 | Heated Seat Controls |
| 15 | Not Used |
| 16 | Remote Keyless Entry System, XM Satellite Radio, Rear Seat Entertainment System, Homelink |
| 17 | Back-up Lamps |
| 18 | Not Used |
| 19 | Not Used |
| 20 | Cigarette Lighter, Auxiliary Power Outlet |
| 21 | Not Used |
| 22 | Trunk |
| 23 | Rear Window Defogger |
| 24 | Heated Mirror Controls |
| 25 | Fuel Pump |
| Relays | |
| 26 | Rear Window Defogger |
| 27 | Parklamps |
| 28 | Not Used |
| 29 | Not Used |
| 30 | Not Used |
| 31 | Not Used |
| 32 | Not Used |
| 33 | Back-up Lamps |
| 34 | Not Used |
| 35 | Not Used |
| 36 | Trunk |
| 37 | Fuel Pump |
| 38 (Diode) | Trunk, Cargo Lamps |
