Categories: Ford

Ford Everest (2015-2019..) fuses and relays

In this article, we consider the third-generation Ford Everest, available from 2015 to the present. Here you will find fuse box diagrams of Ford Everest 2015, 2016, 2017, 2018 and 2019, get information about the location of the fuse panels inside the car, and learn about the assignment of each fuse (fuse layout) and relay.

Fuse Layout Ford Everest 2015-2019..

Contents

Cigar lighter (power outlet) fuses in the Ford Everest are the fuses №5 (Power point 3 (console rear)), №10 (Power point 1 / cigar lighter), №16 (Power point 2 / cigar lighter) and №17 (Power point 4 – 3rd row power point) in the Engine compartment fuse box.

Table of Contents

Fuse box location

Passenger compartment

This fuse box is located behind the cover on the instrument panel.

Engine compartment (Power Distribution Box)

Lift the release lever at the rear of the cover to remove it.

Power Distribution Box – Bottom

There are fuses on the bottom of the fuse box. To access the bottom of the fuse box:

1) Release the two latches on both sides of the fuse box.
2) Raise the rear side of the fuse box from the cradle.
3) Move the fuse box toward the rear side of the engine compartment and rotate as shown.
4) Pivot the rear side of the fuse box to access the bottom side.
5) Release the two latches to open the fuse cover.

High Current Fuse Box

It is located in the engine compartment below the engine compartment fuse box. This box contains several high current fuses.

Pre-Fuse Box

It is attached to the positive battery terminal.

Fuse box diagrams

2015, 2016, 2017 and 2018

Passenger compartment

Assignment of the fuses in the Passenger compartment (2015-2018)

№	Amp Rating	Protected Components
1	10	Demand lamp / battery saver – overhead console, automatic transmission gear shifter, glove box lamp, sun visor, grab handle, Map lamps.
2	7.5	Not used (spare).
3	20	Driver door latch /fuel flap unlock relay. Door double/aux lock relay.
4	5	Not used (spare).
5	20	Subwoofer amplifier.
6	10	Not used (spare).
7	10	Not used (spare).
8	10	Security horn.
9	10	Not used (spare).
10	5	Power liftgate module.
11	5	Interior motion sensor.
12	7.5	Electronic control panel, climate control module, rear auxiliary module.
13	7.5	Instrument cluster, steering column control module, smart data link connector.
14	10	Not used (spare).
15	10	Gateway module/smart data link connector – OBD II (RHD).
16	15	Child lock.
17	5	Battery backed sounder.
18	5	Ignition switch.
19	7.5	Not used (spare).
20	7.5	Headlamp control module (if fitted).
21	5	Humidity and in car temperature sensor.
22	5	Not used (spare).
23	10	Inverter, door lock switch, moon roof, driver door window switch (one touch up/down all doors.
24	20	Central locking system.
25	30	Driver door control module (power window one touch up/down all doors) Driver door power window switch memory (with one touch up/down driver only)
26	30	Passenger door control module (power window – one touch up/down).
27	30	Moonroof.
28	20	Not used (spare).
29	30	Left rear door control module (power window – one touch up/down).
30	30	Right rear door control module (power window – one touch up/down).
31	15	Not used (spare).
32	10	Radio transceiver module, SYNC, global positioning system module, multi function display, door entry remote.
33	20	Audio unit.
34	30	Run/start relay.
35	5	Restraints control module.
36	15	Interior rear view mirror electrochromatic.
37	15	Not used (spare).
38	30	Power windows (without door control module – with one touch up/down driver only).

Engine compartment

Assignment of the fuses and relays in the Engine compartment (2015-2018)

№	Amp Rating	Protected Components
1	25	Not used.
2	–	Starter motor solenoid relay.
3	15	Rear wiper, rain sensor.
4	–	Front blower motor relay.
5	20	Power point 3 (console rear).
6	–	Headlamp low beam relay (high intensity discharge).
7	20	Powertrain control module.
8	20	Power train control module – volumetric control valve, EGR cooler bypass, TMAF.
9	–	Powertrain control module relay.
10	20	Power point 1 / cigar lighter.
11	15	Powertrain control module – NOX sensor (if fitted).
12	15	Powertrain control module – fan drive, glow plug control module.
13	15	Not used.
14	15	Not used.
15	–	Run/start relay.
16	20	Power point 2 / cigar lighter.
17	20	Power point 4 – 3rd row power point.
18	10	Not used.
19	10	Electric power assisted steering.
20	10	Headlamp switch, headlamp levelling motor.
21	15	Transfer case control module – terrain management switch.
22	10	Air conditioning compressor.
23	15	Parking aid rear view camera, blind spot monitoring module, adaptive speed control radar and heads up display (if fitted).
24	5	Exhaust emissions – rear dosing control module (if fitted).
25	10	Anti-lock brake system.
26	10	Mirror adjust switch.
27	5	PTC Heater (if fitted).
28	10	Powertrain control module.
29	10	Rear window washer pump.
30	–	Not used.
31	–	Not used.
32	–	Not used.
33	–	Air conditioning clutch relay.
34	–	Not used.
35	15	Transmission control module.
36	–	Not used.
37	10	Heated exterior mirror.
38	–	Not used.
39	–	Not used.
40	–	Fuel pump relay.
41	–	Horn relay.
42	–	Seat third row power fold relay.
43	15	Exhaust emissions – rear dosing control module (if fitted).
44	25	Headlamp washer pump.
45	–	Not used.
46	10	Not used.
47	10	Brake pedal switch.
48	20	Horn.
49	5	Not used.
50	15	Exhaust emissions – rear dosing control module (if fitted).
51	–	Not used.
52	–	Not used.
53	–	Not used.
54	10	Exhaust emissions – rear dosing control module (if fitted).
55	10	Exhaust emissions – rear dosing control module (if fitted).
86	–	Rear blower motor relay.

Power Distribution Box – Bottom

Assignment of the fuses and relays in the Engine compartment (bottom) (2015-2018)

№	Amp Rating	Protected Components
56	30	Fuel pump control module.
57	–	Not used.
58	–	Not used.
59	–	Not used.
60	–	Not used.
61	–	Not used.
62	50	Body control module 1 (lighting).
63	–	Not used.
64	20	Trailer auxilliary.
65	20	Heated front seats.
66	–	Not used.
67	50	Body control module 2 (lighting).
68	40	Rear window defroster.
69	30	Antilock brake system valves.
70	20	Passenger power seat.
71	–	Not used.
72	30	Third row power fold seat.
73	–	Not used.
74	20	Driver power seat.
75	25	Rear blower motor.
76	20	Left-hand low beam high-intensity discharge headlamps (if fitted).
77	25	AWD module.
78	25	AWD module.
79	40	Blower motor.
80	20	Right-hand low beam high-intensity discharge headlamps (if fitted).
81	40	Inverter.
82	60	Anti-lock brake system pump.
83	25	Windshield wiper motor.
84	30	Starter motor solenoid.
85	30	Power lift gate module.
87	40	Trailer module.

High Current Fuse Box

№	Amp Rating	Protected Components
1	60	Glow plug module.
2	125	Body control module.
3	50	Body control module.
4	–	Busbar through to power distribution box.
5	100	PTC Heater (if fitted).

Pre-Fuse Box

№	Amp Rating	Protected Components
1	225	Alternator.
2	125	Electronic power assist steering.

2019

Passenger compartment

Assignment of the fuses in the Passenger compartment (2019)

№	Amp Rating	Protected Component
1	–	Not used.
2	7.5 A	Not used (spare).
3	20A	Driver door latch. Fuel flap unlock relay.
4	5A	Not used (spare).
5	20A	Subwoofer amplifier.
6	10A	Not used (spare).
7	10A	Not used (spare).
8	10A	Security horn.
9	10A	Not used (spare).
10	5A	Power liftgate module. Liftgate hands-free entry.
11	5A	Interior motion sensor.
12	7.5 A	Electronic control panel. Climate control module. Rear auxiliary module.
13	7.5 A	Instrument cluster. Steering column control module. Data link connector.
14	10A	Not used (spare).
15	10A	Gateway module. Data link connector.
16	15A	Not used (spare).
17	5A	Battery backed sounder.
18	5A	Push button start.
19	7.5 A	Not used (spare).
20	7.5 A	Exhaust emissions – reductant dosing control module.
21	5A	Humidity and in car temperature sensor.
22	5A	Not used (spare).
23	10A	Inverter. Door lock switch. Moonroof. Driver door window switch (one touch up/down all doors).
24	20A	Central locking system.
25	30A	Driver door control module (power window – one touch up/down all doors).
26	30A	Passenger door control module (power window – one touch up/down).
27	30A	Moonroof.
28	20A	Not used (spare).
29	30A	Left rear door control module (power window – one touch up/down).
30	30A	Right rear door control module (power window – one touch up/down).
31	15A	Not used (spare).
32	10A	Radio transceiver module. SYNC. Global positioning system module. Multi-function display. Door entry remote.
33	20A	Audio unit.
34	30A	Run/start relay.
35	5A	Restraints control module.
36	15A	Auto-dimming interior mirror. Mirror adjustment control.
37	20A	Transfer case control module.
38	30A	Not used (spare).

Engine compartment

Assignment of the fuses and relays in the Engine compartment (2019)

№	Amp Rating	Protected Component
1	15A	Rear wiper.
2	–	Starter motor solenoid relay.
3	5A	Rain sensor.
4	–	Front blower motor relay.
5	20A	Auxiliary power point 3 – console rear.
6	–	High-intensity discharge headlamp low beam relay.
7	20A	Powertrain control module.
8	20A	Volumetric control valve (3.2L) cooler bypass (3.2L). Temperature mass air flow (3.2L). cooler bypass control – vacuum solenoid valve (2.0L)
9	–	Powertrain control module relay.
10	20A	Auxiliary power point 1 – instrument panel.
11	15A	Nitrogen oxide sensors (3.2L). Glow plug module (2.0L).
12	15A	Fan. Glow plug module (3.2L). Turbo bypass valve actuator (2.OL). Wastegate actuator (2.OL). A/C compressor and control valve (2.0L). Coolant pump (2.0L).
13	15A	Not used.
14	15A	Not used.
15	–	Run/start relay.
16	20A	Auxiliary power point 2 – instrument panel.
17	20A	Auxiliary power point 4 – third row power point.
18	10A	Fuel pump relay coil (3.2L).
19	10A	Electric power assisted steering.
20	10A	Headlamp switch. Headlamp leveling motor. Headlamp control module.
21	15A	Transmission control module (automatic transmission). Transmission (10-speed automatic transmission).
22	10A	Air conditioning compressor.
23	7.5 A	Parking aid rear view camera (3.2L). Blind spot monitoring module (3.2L). Adaptive speed control radar (3.2L). Head up display (3.2L). Terrain management switch (3.2L). Voltage quality module (2.OL).
24	5A	Not used (spare).
25	10A	Anti-lock brake system.
26	10A	Not used (spare).
27	–	Not used.
28	10A	Powertrain control module.
29	10A	Rear window washer pump.
30	–	Not used.
31	–	Not used.
32	–	Not used (3.2L). Water-in-fuel filter heater relay (2.0L).
33	–	Air conditioning clutch relay.
34	20A	Steering column lock.
35	15A	Transmission control module.
36	–	Not used.
37	10A	Heated exterior mirror.
38	–	Not used.
39	–	Not used.
40	–	Fuel pump relay.
41	–	Horn relay.
42	–	Third row seat power fold relay.
43	15A	Exhaust emissions – reductant dosing control module.
44	–	Not used.
45	–	Not used.
46	10A	Not used (spare).
47	10A	Brake pedal switch.
48	20A	Horn.
49	5A	Not used (spare) (3.2L). Water-in-fuel filter heater relay coil feed (2.0L).
50	15A	Exhaust emissions – reductant dosing control module.
51	–	Not used.
52	–	Not used.
53	–	Not used.
54	10A	Exhaust emissions – reductant dosing control module (3.2L). Not used (spare) (2.0L).
55	10A	Exhaust emissions – reductant dosing control module.
86	–	Rear blower motor relay.

Power Distribution Box – Bottom

Assignment of the fuses and relays in the Engine compartment (bottom) (2019)

№	Amp Rating	Protected Component
56	30A	Fuel pump control module.
57	15A	Not used (spare).
58	–	Not used.
59	–	Not used.
60	40A	Not used (spare) (3.2L). Water-in-fuel filter heater (2.0L).
61	–	Not used.
62	50A	Body control module 1 – lighting.
63	–	Not used.
64	20A	Trailer tow connector.
65	20A	Heated front seats.
66	–	Not used.
67	50A	Body control module 2 – lighting.
68	40A	Rear window defroster.
69	30A	Anti-lock brake system valves.
70	20A	Passenger power seat.
71	–	Not used.
72	30A	Third row power fold seat.
73	30A	Trailer module.
74	20A	Driver power seat.
75	25A	Rear blower motor.
76	20A	Left-hand low beam high-intensity discharge headlamps.
77	25A	module.
78	30A	module.
79	40A	Front blower motor.
80	20A	Right-hand low beam high-intensity discharge headlamps.
81	40A	Inverter.
82	60A	Anti-lock brake system pump.
83	30A	Windshield wiper motor.
84	30A	Starter motor solenoid.
85	30A	Power liftgate module.
87	40A	Trailer module.

High Current Fuse Box

№	Amp Rating	Protected Component
1	70A	Glow plug module.
2	125A	Body control module.
3	50A	Body control module (vehicles without start-stop). Voltage quality module – rear parking aid camera, adaptive cruise control, head up display, (vehicles with start-stop).
4	–	Busbar through to power distribution box.